A high-throughput quantification of resin and rubber contents in Parthenium argentatum using near-infrared (NIR) spectroscopy

Plant Methods - Tập 15 Số 1 - 2019
Zinan Luo1, Kelly R. Thorp1, Hussein Abdel‐Haleem1
1US Arid-Land Agricultural Research Center, USDA-ARS, Maricopa, AZ, 85138, USA

Tóm tắt

Abstract Background Guayule (Parthenium argentatum A. Gray), a plant native to semi-arid regions of northern Mexico and southern Texas in the United States, is an alternative source for natural rubber (NR). Rapid screening tools are needed to replace the current labor-intensive and cost-inefficient method for quantifying rubber and resin contents. Near-infrared (NIR) spectroscopy is a promising technique that simplifies and speeds up the quantification procedure without losing precision. In this study, two spectral instruments were used to rapidly quantify resin and rubber contents in 315 ground samples harvested from a guayule germplasm collection grown under different irrigation conditions at Maricopa, AZ. The effects of eight different pretreatment approaches on improving prediction models using partial least squares regression (PLSR) were investigated and compared. Important characteristic wavelengths that contribute to prominent absorbance peaks were identified. Results Using two different NIR devices, ASD FieldSpec®3 performed better than Polychromix Phazir™ in improving R2 and residual predicative deviation (RPD) values of PLSR models. Compared to the models based on full-range spectra (750–2500 nm), using a subset of wavelengths (1100–2400 nm) with high sensitivity to guayule rubber and resin contents could lead to better prediction accuracy. The prediction power of the models for quantifying resin content was better than rubber content. Conclusions In summary, the calibrated PLSR models for resin and rubber contents were successfully developed for a diverse guayule germplasm collection and were applied to roughly screen samples in a low-cost and efficient way. This improved efficiency could enable breeders to rapidly screen large guayule populations to identify cultivars that are high in rubber and resin contents.

Từ khóa


Tài liệu tham khảo

Luo Z, Iaffaldano BJ, Zhuang XF, Fresnedo-Ramirez J, Cornish K. Analysis of the first Taraxacum kok-saghyz transcriptome reveals potential rubber yield related SNPs. Sci Rep. 2017;7(9939):1–13.

Suchat S, Pioch D, Palu S, Tardan E, van Loo EN, Davrieux F. Fast determination of the resin and rubber content in Parthenium argentatum biomass using near infrared spectroscopy. Ind Crop Prod. 2013;45:44–51.

van Beilen JB, Poirier Y. Guayule and Russian dandelion as alternative sources of natural rubber. Crit Rev Biotechnol. 2007;27(4):217–31.

Cornish K, Myers MD, Kelley SS. Latex quantification in homogenate and purified latex samples from various plant species using near infrared reflectance spectroscopy. Ind Crop Prod. 2004;19(3):283–96.

Derodriguez DJ, Kuruvadi S. Comparison of soxhlet and homogenizer extraction methods to determine rubber and resin content of mexican guayule plants. Bioresour Technol. 1991;35(2):179–83.

Black LT, Hamerstrand GE, Kwolek WF. Analysis of rubber, resin, and moisture-content of guayule by near-infrared reflectance spectroscopy. Rubber Chem Technol. 1985;58(2):304–13.

Schloman WW, Carlson DW, Hilton AS. Guayule extractables-influence of extraction conditions on yield and composition. Biomass. 1988;17(4):239–49.

Cornish K, Pearson CH, Rath DJ. Accurate quantification of guayule resin and rubber requires sample drying below a critical temperature threshold. Ind Crop Prod. 2013;41:158–64.

Richter BE, Jones BA, Ezzell JL, Porter NL, Avdalovic N, Pohl C. Accelerated solvent extraction: a technique for sample preparation. Anal Chem. 1996;68(6):1033–9.

Ramirez-Cadavid DA, Valles-Ramirez S, Cornish K, Michel FC. Simultaneous quantification of rubber, inulin, and resins in Taraxacum kok-saghyz (TK) roots by sequential solvent extraction. Ind Crop Prod. 2018;122:647–56.

Salvucci ME, Coffelt TA, Cornish K. Improved methods for extraction and quantification of resin and rubber from guayule. Ind Crop Prod. 2009;30(1):9–16.

Jin XL, Chen XL, Shi CH, Li M, Guan YJ, Yu CY, Yamada T, Sacks EJ, Peng JH. Determination of hemicellulose, cellulose and lignin content using visible and near infrared spectroscopy in Miscanthus sinensis. Bioresour Technol. 2017;241:603–9.

Lin C, Chen X, Jian L, Shi CH, Jin XL, Zhang GP. Determination of grain protein content by near-infrared spectrometry and multivariate calibration in barley. Food Chem. 2014;162:10–5.

Aernouts B, Van Beers R, Watte R, Huybrechts T, Lammertyn J, Saeys W. Visible and near-infrared bulk optical properties of raw milk. J Dairy Sci. 2015;98(10):6727–38.

Prevolnik M, Skrlep M, Janes L, Velikonja-Bolta S, Skorjanc D, Candek-Potokar M. Accuracy of near infrared spectroscopy for prediction of chemical composition, salt content and free amino acids in dry-cured ham. Meat Sci. 2011;88(2):299–304.

Sparen A, Hartman M, Fransson M, Johansson J, Svensson O. Matrix effects in quantitative assessment of pharmaceutical tablets using transmission raman and near-infrared (NIR) spectroscopy. Appl Spectrosc. 2015;69(5):580–9.

Kopicky SE. The use of near infrared spectroscopy in rubber quantification. Columbus: The Ohio State University; 2014.

Taurines M, Brancheriau L, Palu S, Pioch D, Tardan E, Boutahar N, Sartre P, Meunier F. Determination of natural rubber and resin content of guayule fresh biomass by near infrared spectroscopy. Ind Crop Prod. 2019;134:177–84.

Luo Z, Abdel-Haleem H. Phenotypic diversity of USDA guayule germplasm collection grown under T different irrigation conditions. Ind Crop Prod. 2019. https://doi.org/10.1016/j.indcrop.2019.111867.

Hunsaker DJ, Elshikha DM. Surface irrigation management for guayule rubber production in the US desert Southwest. Agr Water Manag. 2017;185:43–57.

Palou A, Miro A, Blanco M, Larraz R, Gomez JF, Martinez T, Gonzalez JM, Alcala M. Calibration sets selection strategy for the construction of robust PLS models for prediction of biodiesel/diesel blends physico-chemical properties using NIR spectroscopy. Spectrochim Acta A. 2017;180:119–26.

Eide I, Westad F. Automated multivariate analysis of multi-sensor data submitted online: real-time environmental monitoring. Plos ONE. 2018;13(1):e0189443.

Fried R, Einbeck J, Gather U. Weighted Repeated median smoothing and filtering. J Am Stat Assoc. 2007;102(480):1300–8.

Panchuk V, Semenov V, Legin A, Kirsanov D. Signal smoothing with PLS regression. Anal Chem. 2018;90(9):5959–64.

Delwiche SR, Reeves JB. The effect of spectral pre-treatments on the partial least squares modelling of agricultural products. J Near Infrared Spec. 2004;12(3):177–82.

Luypaert J, Zhang MH, Massart DL. Feasibility study for the use of near infrared spectroscopy in the qualitative and quantitative analysis of green tea, Camellia sinensis (L.). Anal Chim Acta. 2003;478(2):303–12.

Savitzky A, Golay MJE. Smoothing + differentiation of data by simplified least squares procedures. Anal Chem. 1964;36(8):1627.

Rehman NU, Ali L, Al-Harrasi A, Mabood F, Al-Broumi M, Khan AL, Hussain H, Hussain J, Csuk R. Quantification of AKBA in Boswellia sacra using NIRS coupled with PLSR as an alternative method and cross-validation by HPLC. Phytochem Anal. 2018;29(2):137–43.

Martens H, Martens M. Modified Jack-knife estimation of parameter uncertainty in bilinear modelling by partial least squares regression (PLSR). Food Qual Prefer. 2000;11(1–2):5–16.

Bekiaris G, Triolo JM, Peltre C, Pedersen L, Jensen LS, Bruun S. Rapid estimation of the biochemical methane potential of plant biomasses using Fourier transform mid-infrared photoacoustic spectroscopy. Bioresour Technol. 2015;197:475–81.

Williams P. The RPD statistic: a tutorial note. NIR News. 2010;25(1):22–6.

Veatch-Blohm ME, Ray DT. Water stress effects on rubber concentration and rubber distribution in guayule. In: Pascual-Villalobos MJFSN, Bailey CA, Correal E, Schloman WW. Industrial crops and rural development. 2005; p. 607–7.

Gutierrez S, Tardaguila J, Fernandez-Novales J, Diago MP. Data mining and NIR spectroscopy in viticulture: applications for plant phenotyping under field conditions. Sensors. 2016;16(2):236.

de Aragao BJG, Messaddeq Y. Peak separation by derivative spectroscopy applied to FTIR analysis of hydrolized silica. J Brazil Chem Soc. 2008;19(8):1582–94.

Font R, Del Rio-Celestino M, Rosa E, Aires A, De Haro-Bailon A. Glucosinolate assessment in Brassica oleracea leaves by near-infrared spectroscopy. J Agr Sci. 2005;143:65–73.

Font R, Del Rio M, Velez D, Montoro R, De Haro A. Use of near-infrared spectroscopy for determining the total arsenic content in prostrate amaranth. Sci Total Environ. 2004;327(1–3):93–104.

Gonzalez-Martin I, Hernandez-Hierro JM, Bustamante-Rangel M, Barros-Ferreiro N. Near-infrared spectroscopy (NIRS) reflectance technology for the determination of tocopherols in alfalfa. Anal Bioanal Chem. 2006;386(5):1553–8.

Takeno S, Bamba T, Nakazawa Y, Fukusaki E, Okazawa A, Kobayashi A. A high-throughput and solvent-free method for measurement of natural polyisoprene content in leaves by fourier transform near infrared spectroscopy. J Biosci Bioeng. 2008;106(6):537–40.

Osborne B, Fearn T, Hindle P. Practical NIR spectroscopy: with applications in food and beverage analysis. Harlow: Longman Scientific & Technical; 1993.

Kirchler CG, Pezzei CK, Bec KB, Mayr S, Ishigaki M, Ozaki Y, Huck CW. Critical evaluation of spectral information of benchtop vs. portable near-infrared spectrometers: quantum chemistry and two-dimensional correlation spectroscopy for a better understanding of PLS regression models of the rosmarinic acid content in Rosmarini folium. Analyst. 2017;142(3):455–64.

Chan AJ, Steenkeste K, Ely M, Brssn D, Gaboriaud F, Fontaine-Aupart MP. Lipid content in small and large natural rubber particles. Rubber Chem Technol. 2015;88(2):248–57.

Rose K, Steinbuchel A. Biodegradation of natural rubber and related compounds: recent insights into a hardly understood catabolic capability of microorganisms. Appl Environ Microbiol. 2005;71(6):2803–12.

Norgaard L, Saudland A, Wagner J, Nielsen JP, Munck L, Engelsen SB. Interval partial least-squares regression (iPLS): a comparative chemometric study with an example from near-infrared spectroscopy. Appl Spectrosc. 2000;54(3):413–9.

Bangalore AS, Shaffer RE, Small GW, Arnold MA. Genetic algorithm-based method for selecting wavelengths and model size for use with partial least-squares regression: application to near-infrared spectroscopy. Anal Chem. 1996;68(23):4200–12.

Thorp KR, Wang G, Bronson KF, Badaruddin M, Mon J. Hyperspectral data mining to identify relevant canopy spectral features for estimating durum wheat growth, nitrogen status, and grain yield. Comput Electron Agr. 2017;136:1–12.

Chen QS, Jiang P, Zhao JW. Measurement of total flavone content in snow lotus (Saussurea involucrate) using near infrared spectroscopy combined with interval PLS and genetic algorithm. Spectrochim Acta A. 2010;76(1):50–5.

Thông tin
Thông tin xuất bản

Plant Methods

Tập 15 Số 1

Thông tin tác giả