Zeolite-intermittent cycle moving bed air-lift bioreactor (Zeo-ICMBABR) for composting leachate treatment; simultaneous COD, nitrogen and phosphorous compounds removal

Meghdad Pirsaheb1,2, Hiwa Hossaini1,2, Ramin Nabizadeh3,4, Nahid Azizi3,5
1Department of Environmental Health Engineering, Faculty of Health, Kermanshah University of Medical Sciences, Kermanshah, Iran
2Research Center for Environmental Determinants of Health, Kermanshah University of Medical Sciences, Kermanshah, Iran
3Department of Environmental Health Engineering, School of Public Health, Tehran University of Medical Sciences, Tehran, Iran
4Center for Air Quality Research, Institute for Environmental Research (IER), Tehran University of Medical Sciences, Tehran, Iran
5Students Research Committee, Kermanshah University of Medical Sciences, Kermanshah, Iran

Tóm tắt

Anaerobically pretreated composting leachate contains high ammonia load and soluble organic matter, which requires further treatment. In this study, simultaneous removal of COD, nitrogen, and phosphorus compounds from anaerobically pretreated composting leachate investigated by using an intermittent cycle moving bed airlift bioreactor (ICMBABR) supported by zeolite as a biofilm. The efficiency of COD, Total Kjeldahl Nitrogen (TKN), and phosphorous removal and contaminants profile during the process, and the mass balances were analyzed. A multilayer design used for the experimental design, and the effect of four variables including hydraulic retention times (4, 6, 8 h), the zeolite ratios (20, 35, 50%), the influent COD concentration (1, 2, and 3 g/L) and aeration duration (64, 73, and 82%) investigated by Response Surface Methodology (RSM). According to the results and process profile the sequence of anoxic and aerobic conditions, presence of the anaerobic zone in the bottom of the reactor, as well as the use of zeolite as adsorbent media, significantly allowed the simultaneous removal of COD (99%), TKN (95%), and total phosphorus compounds (90%) from anaerobically pretreated composting leachate and favorable potential to remove nitrogen compounds by high efficiency (79%) through simultaneous nitrification and denitrification (SND).

Tài liệu tham khảo

Zhang C, Zeng G, Yuan L, Yu J, Li J, Huang G, et al. Aerobic degradation of bisphenol a by Achromobacter xylosoxidans strain B-16 isolated from compost leachate of municipal solid waste. Chemosphere. 2007;68(1):181–90. https://doi.org/10.1016/j.chemosphere.2006.12.012. Yang S, Yang F, Fu Z, Wang T, Lei R. Simultaneous nitrogen and phosphorus removal by a novel sequencing batch moving bed membrane bioreactor for wastewater treatment. J Hazard Mater. 2010;175(1–3):551–7. https://doi.org/10.1016/j.jhazmat.2009.10.040. Jung J-Y, Chung Y-C, Shin H-S, Son D-H. Enhanced ammonia nitrogen removal using consistent biological regeneration and ammonium exchange of zeolite in modified SBR process. Water Res. 2004;38(2):347–54. https://doi.org/10.1080/09593330.2010.536784. Hung DV, Hoa NTT. An A2O-MBR system for simultaneous nitrogen and phosphorus removal from brewery wastewater. Environ Sci Technol-Science of The Earth & Environment. 2019;3(1):12–22. https://doi.org/10.32508/stdjsee.v3i1.507. Xu X, Qiu L, Wang C, Yang F. Achieving mainstream nitrogen and phosphorus removal through simultaneous partial nitrification, Anammox, Denitrification, and denitrifying phosphorus removal (SNADPR) process in a single-tank integrative reactor. Bioresour Technol. 2019;284:80–9. https://doi.org/10.1016/j.biortech.2019.03.109. Pirsaheb M, Azizi E, Sharafi K, Mohamadi S, Ghayebzadeh M. Removal of organic matter from municipal wastewater using ICMBBR (intermittent cycle moving bed biofilm reactor). Intl Res J Appl Basic Sci Vol. 2015;9(8):1316–22. Pochana K, Keller J. Study of factors affecting simultaneous nitrification and denitrification (SND). Water Sci Technol. 1999;39(6):61–8. https://doi.org/10.1016/S0273-1223(99)00123-7. He S-b, Xue G, Kong H-n, Li X. Improving the performance of sequencing batch reactor (SBR) by the addition of zeolite powder. J Hazard Mater. 2007;142(1–2):493–9. https://doi.org/10.1016/j.jhazmat.2006.08.053. Dutta K, Tsai C-Y, Chen W-H, Lin J-G. Effect of carriers on the performance of anaerobic sequencing batch biofilm reactor treating synthetic municipal wastewater. Int Biodeterior Biodegrad. 2014;95:84–8. https://doi.org/10.1016/j.ibiod.2014.04.021. Wei D, Xue X, Chen S, Zhang Y, Yan L, Wei Q, et al. Enhanced aerobic granulation and nitrogen removal by the addition of zeolite powder in a sequencing batch reactor. AEDL Microbiol Biotechnol. 2013;97(20):9235–43. https://doi.org/10.1007/s00253-012-4625-8. Moghadassi A, Rajabi Z, Hosseini S, Mohammadi M. Preparation and characterization of (PVC-blend-SBR) mixed matrix gas separation membrane filled with zeolite. AJSE. 2014;39(2):605–14. Rice EW, Baird RB, Eaton AD, Clesceri LS. Standard methods for the examination of water and wastewater. Washington, DC: American Public Health Association; 2012. Abyar H, Younesi H, Bahramifar N, Zinatizadeh AA, Amini M. Kinetic evaluation and process analysis of COD and nitrogen removal in UAASB bioreactor. J Taiwan Inst Chem Eng. 2017;78:272–81. https://doi.org/10.1016/j.jtice.2017.06.014. Safari GH, Yetilmezsoy K, Mahvi AH, Zarrabi M. Post-treatment of secondary wastewater treatment plant effluent using a two-stage fluidized bed bioreactor system. J Environ Health Sci Eng. 2013;11(1):10. Anielak AM, Piaskowski K. Influence of zeolites on kinetics and effectiveness of the process of sewage biological purification in sequencing batch reactors. Environ Prot Eng. 2005;31(2):21. Akizuki S, Matsuyama T, Toda T. An anaerobic-aerobic sequential batch system using simultaneous organic and nitrogen removal to treat intermittently discharged organic solid wastes. Process Biochem. 2016;51(9):1264–73. https://doi.org/10.1016/j.wasman.2017.12.013. Pirsaheb M, Mohamadi M, Mansouri AM, Zinatizadeh AAL, Sumathi S, Sharafi K. Process modeling and optimization of biological removal of carbon, nitrogen and phosphorus from hospital wastewater in a continuous feeding & intermittent discharge (CFID) bioreactor. Korean J Chem Eng. 2015;32(7):1340–53. Asadi A, Zinatizadeh A, Van Loosdrecht M, Younesi H. Nitrogen removal by ANAMMOX and simultaneous nitrification–denitrification (SND) processes in a novel single airlift bioreactor. RSC Adv. 2016;6(78):74367–71. https://doi.org/10.1039/C6RA11174B. Wei Y-X, Li Y-F, Ye Z-F. Enhancement of removal efficiency of ammonia nitrogen in sequencing batch reactor using natural zeolite. Environ Earth Sci. 2010;60(7):1407–13. https://doi.org/10.1080/09593330.2010.536784. Khin T, Annachhatre AP. Novel microbial nitrogen removal processes. Biotechnol Adv. 2004;22(7):519–32. https://doi.org/10.1016/j.biotechadv.2004.04.003. Qasim SR, Zhu G. Wastewater treatment and reuse, theory and design examples, volume 1: principles and basic treatment: CRC Press; 2017. Islam M, Xu Q, Yuan Q. Advanced biological sequential treatment of mature landfill leachate using aerobic activated sludge SBR and fungal bioreactor. J Environ Health Sci Eng. 2020:1–11. Rahimi Y, Torabian A, Mehrdadi N, Shahmoradi B. Simultaneous nitrification–denitrification and phosphorus removal in a fixed bed sequencing batch reactor (FBSBR). J Hazard Mater. 2011;185(2–3):852–7. https://doi.org/10.1016/j.jhazmat.2010.09.098. Ghehi TJ, Mortezaeifar S, Gholami M, Kalantary RR, Mahvi AH. Performance evaluation of enhanced SBR in simultaneous removal of nitrogen and phosphorous. J Environ Health Sci Eng. 2014;12(1):134.