Characterisation and optimisation of PECVD SiNx as an antireflection coating and passivation layer for silicon solar cells

AIP Advances - Tập 3 Số 3 - 2013
Yimao Wan1, Keith R. McIntosh2, Andrew Thomson1
1The Australian National University (ANU) 1 Research School of Engineering, , Canberra ACT 0200, Australia
2PV Lighthouse 2 , Coledale NSW 2515, Australia

Tóm tắt

In this work, we investigate how the film properties of silicon nitride (SiNx) depend on its deposition conditions when formed by plasma enhanced chemical vapour deposition (PECVD). The examination is conducted with a Roth & Rau AK400 PECVD reactor, where the varied parameters are deposition temperature, pressure, gas flow ratio, total gas flow, microwave plasma power and radio-frequency bias voltage. The films are evaluated by Fourier transform infrared spectroscopy to determine structural properties, by spectrophotometry to determine optical properties, and by capacitance–voltage and photoconductance measurements to determine electronic properties. After reporting on the dependence of SiNx properties on deposition parameters, we determine the optimized deposition conditions that attain low absorption and low recombination. On the basis of SiNx growth models proposed in the literature and of our experimental results, we discuss how each process parameter affects the deposition rate and chemical bond density. We then focus on the effective surface recombination velocity Seff, which is of primary importance to solar cells. We find that for the SiNx prepared in this work, 1) Seff does not correlate universally with the bulk structural and optical properties such as chemical bond densities and refractive index, and 2) Seff depends primarily on the defect density at the SiNx-Si interface rather than the insulator charge. Finally, employing the optimized deposition condition, we achieve a relatively constant and low Seff,UL on low-resistivity (≤1.1 Ωcm) p- and n-type c-Si substrates over a broad range of n = 1.85–4.07. The results of this study demonstrate that the trade-off between optical transmission and surface passivation can be circumvented. Although we focus on photovoltaic applications, this study may be useful for any device for which it is desirable to maximize light transmission and surface passivation.

Từ khóa


Tài liệu tham khảo

2001, Solar Energy Materials and Solar Cells, 65, 239, 10.1016/S0927-0248(00)00099-4

1996, Solar Energy Materials and Solar Cells, 40, 297, 10.1016/0927-0248(95)00155-7

2010, Proc. 35th IEEE PVSC, 3205

1985, Solid State Technology, 28, 197

1994, Applied Physics Letters, 65, 2078, 10.1063/1.112798

2003, Photovoltaic Energy Conversion, 2003. Proceedings of 3rd World Conference on, 1131

2006, Applied Physics Letters, 89, 013508, 10.1063/1.2219142

2003, Journal of Vacuum Science & Technology B: Microelectronics and Nanometer Structures, 21, 2123, 10.1116/1.1609481

1998, Journal of Vacuum Science & Technology A: Vacuum, Surfaces, and Films, 16, 530, 10.1116/1.581095

2002, Journal of Applied Physics, 92, 2602, 10.1063/1.1495529

2004, Progress in Photovoltaics: Research and Applications, 12, 21, 10.1002/pip.523

2009, Solar Energy Materials and Solar Cells, 93, 1281, 10.1016/j.solmat.2009.01.023

2011, Photovoltaic Specialists Conference (PVSC), 2011 37th IEEE, 001421

2001, Solar Energy Materials and Solar Cells, 65, 585, 10.1016/S0927-0248(00)00145-8

2012, 1

2012, Physical Review B, 86, 165202, 10.1103/PhysRevB.86.165202

1990, Journal of Vacuum Science & Technology B: Microelectronics and Nanometer Structures, 8, 551, 10.1116/1.585008

2004, Journal of Vacuum Science & Technology A: Vacuum, Surfaces, and Films, 22, 96, 10.1116/1.1631294

2006, Journal of Applied Physics, 100, 093303, 10.1063/1.2358330

2011, Journal of Applied Physics, 109, 073521, 10.1063/1.3569890

1996, Applied Physics Letters, 69, 2510, 10.1063/1.117723

1998, Philosophical Magazine Part B, 77, 925, 10.1080/13642819808206395

1983, physica status solidi (b), 118, 463, 10.1002/pssb.2221180202

1997, Appl. Opt., 36, 7826, 10.1364/AO.36.007826

2012, Energy Procedia, 15, 78, 10.1016/j.egypro.2012.02.009

n

1995, Applied Physics Letters, 66, 2828, 10.1063/1.113443

2002, Semiconductor Science and Technology, 17, 166, 10.1088/0268-1242/17/2/314

1996, Applied Physics Letters, 69, 517, 10.1063/1.117772

1980, Thin Solid Films, 67, 309, 10.1016/0040-6090(80)90464-2

2000, Journal of Vacuum Science & Technology A: Vacuum, Surfaces, and Films, 18, 2619, 10.1116/1.1314395

1991, Philosophical Magazine Part B, 63, 47, 10.1080/01418639108224430

2005, Photovoltaic Specialists Conference, 2005. Conference Record of the Thirty-first IEEE, 1043

2006, Photovoltaic Energy Conversion, Conference Record of the 2006 IEEE 4th World Conference on, 1148

2007, 22nd European Photovoltaic Solar Energy Conference, 1053

2006, Applied Physics Letters, 89, 211914, 10.1063/1.2396900

1962, Solid-State Electronics, 5, 285, 10.1016/0038-1101(62)90111-9

2005, Progress in Photovoltaics: Research and Applications, 13, 705, 10.1002/pip.628

2004, Applied Physics Letters, 85, 4061, 10.1063/1.1812833

Thông tin
Thông tin xuất bản

AIP Advances

Tập 3 Số 3

Thông tin tác giả