Vergiftungserscheinungen bei dicyclohexyl-methan-4-4′-diisocyanat-exposition
Tóm tắt
Vergiftungen durch organische Isocyanate (OI) sind schon seit dem Zweiten Weltkrieg bekannt. Die bekanntesten OI sind Toluylen-Diisocyanat (TDI), Diphenyl-Methan-Diisocyanat (MDI), Naphtylen-Diisocyanat (NDI) and Hexamethylen-Diisocyanat (HDI). Alle oben erwdhnten organischen Isocyanate werden für verschiedenartige Zwecke zu Polyurethane polymerisiert. Das Dicyclohexyl-Methane-4-4′-Diisocyanate (DMDI) wird zur Zeit für Flaschenüberzüge in Japan and Israel benötigt, um so evtl. Verletzungen durch Glasscherben zu verhindern. Elf von 15 Arbeitnehmern, die zuerst DMDI exponiert waren, zeigten vier bis sieben Tage nach Beginn der Exposition verschiedenartige Hautaffektionen im Bereich der unbedeckten Körperteile. Sechs litten an Vertigo mit oder ohne Kopfschmerzen und vier zeigten obstruktive Ventilationsstörungen, Tachykardie und Hypotension (EKG-Normal-Befund). Alle werden oral mit Antihistaminica und lokal mit Steroiden mit gutem Erfolg behandelt. Es konnten keine Unterschiede zwischen den Arbeitern der atopischen und der nicht-atopischen Gruppe festgestellt werden. Alle Zeichen der Vergiftung verschwanden nach 10 bis 14tägiger Behandlung. DMDI scheint nicht die Atemwege so stark anzugreifen wie TDI. Mögliche chronische Schädigungen werden diskutiert. Die Schwierigkeiten, DMDI in der Luft zu messen, werden festgestellt (MAK = 0,003 ppm).
Tài liệu tham khảo
Heinrich G, Brugsh MD, Elkins HB (1963) Toluene diisocyanate (TDI) toxicity. N Engl J Med 268 [7]:353–357
Fuchs S, Valade P (1951) Etude clinique et experimentale sur quelques cas d'intoxication par le desmodur T (diisocyanate de toluylene 2–4 et 1-2-6). Arch Mat Prof 12:191–196
Dharmarajan V, Weill H (1978) Physical state of airborne p-p′-diphenyl-methane diisocyanate (MDI) and its measurement. Am Ind Hyg Assoc J 39:737–744
General Industry Safety and Health Standards (1976) US Department of Labor, Occupational Safety and Health Administration, OSHA 2206 (29 CFR 1910), Revised in Jan 1976
Konzen R, Graft B, Schell L, Gorski C (1966) Human response to low concentrations of p-p′-diphenylmethane diisocyanate (MDI). Am Ind Hyg Assoc J 27:121–127
N.I.O.S.H. (1977) Manual of Analytical Methods, 2nd ed, vol 1. Method No P&CAM 142, DG Taylor Manual Co-ordinator, US Department of HEW, NIOSH
Lowe A (1970) The chemistry of isocyanates. Proc Roy Soc Med 63 [1]:367–368
Buist JM (1970) Isocyanates in industry. Proc Roy Soc Med 63 [1]:365–367
O'Brien M, Harries MG, Burge PS, Pepys J (1979) Toluene diisocyanate-induced asthma. Clin Allergy 9:1–6
Wegmann DH, Peters JM, Pagnotto L, Fine J (1977) Chronic pulmonary function loss from exposure to toluene diisocyanate. Br J Ind Med 34:196–200
Taylor G (1970) Immune responses to toluene diisocyanate (TDI) exposure in man. Proc Roy Soc Med 63 [1]:379–380
Karol MH, Ioset HH, Alaric WC (1978) Toly-specific IgE antibodies in workers with hypersensitivity to toluene diisocyanate. Abstr Am Ind Hyg Conf, May 1978
Austen KF (1973) Systemic anaphylaxis in the human being. N Engl J Med 291:277–279
O'Brien IM, Newman AJ, Burge PS, Harries MG, Fawcett IW, Pepys J (1979) Toluene diisocyanate-induced asthma. Clin Allergy 9:7–15
Peters JM (1970) Cumulative pulmonary effects in workers exposed to tolylene diisocyanate. Proc Roy Soc Med 63 [1]:372–375
Peters JM, Wegman DH (1975) Epidemiology of toluene diisocyanate (TDI) induced respiratory disease. Environ Health Perspect 11:97–100
Wegmann DH, Peters JM, Pagnotto L, Fine L (1977) Chronic pulmonary function loss from exposure to toluene diisocyanate. Br J Ind Med 34:195–200
Lazareva L (1976) Substances used in industry, vol 2 (in Russian). Chemistry Publ, Leningrad, pp 126–127
Konzen RB, Craft BF, Scheel LD, Zorski CH (1964) Human response to los concentrations of p-p-diphenyl-methane-diisocyanate (MDI). Am Ind Hyg Assoc J 27:121–125