Utilization of sawdust as a pore-former in the fabrication of ceramic adsorbents for water purification

Journal of the Australian Ceramic Society - Tập 58 - Trang 1297-1309 - 2022
Kazeem A. Salami1,2, David O. Obada1,2,3, Abdulmumin A. Alabi1, Stefan Csaki4, Ayodeji N. Oyedeji1,2
1Department of Mechanical Engineering, Ahmadu Bello University, Zaria, Nigeria
2Multifunctional Materials Laboratory, Shell Office Complex, Department of Mechanical Engineering, Ahmadu Bello University, Zaria, Nigeria
3Africa Centre of Excellence on New Pedagogies in Engineering Education, Ahmadu Bello University, Zaria, Nigeria
4Department of Physics, Constantine the Philosopher University in Nitra, Nitra, Slovakia

Tóm tắt

In this study, kaolin-based ceramic materials with sawdust addition (10 and 20 wt.%) were fabricated using a two-level full factorial design of experiments. Next, the effect of sintering temperature and compaction pressure on the physical, chemical, and mechanical properties of the ceramic materials was investigated. From these experiments, an optimum composition was selected and used to fabricate ceramic adsorbents. The filtration efficacy of the optimum adsorbent was tested by evaluating the filtration dynamics of water contaminated with heavy metals like zinc (Zn), copper (Cu), nickel (Ni), cadmium (Cd), and lead (Pb), and compared with an adsorbent fabricated without the inclusion of the pore former (sawdust). These experiments resulted in a higher heavy metal removal efficiency for the optimum adsorbent of approximately 3%, 61%, and 76% for Cu, Zn, and Ni, respectively, compared with 1%, 5.6%, and 6.4% as obtained for the adsorbent with no pore former. Nonetheless, the optimum ceramic adsorbent showed low efficiency towards the removal of Pb.

Tài liệu tham khảo

Yang, S.M., Coombs, N., Ozin, G.A.: Micromolding in inverted polymer opals (MIPO): synthesis of hexagonal mesoporous silica opals. Adv. Mater. 12(24), 1940–1944 (2000) Fabrication and crack deflection in ceramic laminates with porous interlayers Dong, B.B., Wang, F.H., Yang, M.Y., Yu, J.L., Hao, L.Y., Xu, X., Agathopoulos, S.: Polymer-derived porous SiOC ceramic membranes for efficient oil-water separation and membrane distillation. J. Membr. Sci. 579, 111–119 (2019) Obada, D.O., Dodoo-Arhin, D., Dauda, M., Anafi, F.O., Ahmed, A.S., Ajayi, O.A.: Physico-mechanical and gas permeability characteristics of kaolin based ceramic membranes prepared with a new pore-forming agent. Appl. Clay Sci. 150, 175–183 (2017) Obada, D.O., Dodoo-Arhin, D., Dauda, M., Anafi, F.O., Ahmed, A.S., Ajayi, O.A.: Pressureless sintering and gas flux properties of porous ceramic membranes for gas applications. Results Phys. 7, 3838–3846 (2017) Guzman, I.Y.: Certain principles of formation of porous ceramic structures. Properties and applications (a review). Glas. Ceram. 60(9), 280–283 (2003) Taslicukur, Z., Balaban, C., Kuskonmaz, N.: Production of ceramic foam filters for molten metal filtration using expanded polystyrene. J. Eur. Ceram. Soc. 27(2–3), 637–640 (2007) Sandford, P., Sibley, S.R.: Optimization of Al casting productivity using foam filter technology and application. AFS Transac. 227, 1063–1068 (1996) Chen, F., Shen, Q., Yan, F., Zhang, L.: Pressureless sintering of α-Si3N4 porous ceramics using a H3PO4 pore-forming agent. J. Am. Ceram. Soc. 90(8), 2379–2383 (2007) Ohji, T., Fukushima, M.: Macro-porous ceramics: processing and properties. Int. Mater. Rev. 57(2), 115–31 (2012) Studart, A.R., Gonzenbach, U.T., Tervoort, E., Gauckler, L.J.: Processing routes to macroporous ceramics: a review. J. Am. Ceram. Soc. 89(6), 1771–1789 (2006) Rice, R.W.: Ceramic fabrication technology. CRC Press, 2002, 1st edition (November 8, 2002), 376 pages Scheffler, M., Colombo P.: Cellular ceramics: structure, manufacturing, properties and applications. John Wiley & Sons, Weinheim Wiley-VCH 2005 Obada, D.O., Dodoo-Arhin, D., Dauda, M., Anafi, F.O., Ahmed, A.S., Ajayi, O.A.: The impact of kaolin dehydroxylation on the porosity and mechanical integrity of kaolin based ceramics using different pore formers. Results Phy. 7, 2718–2727 (2017) Obada, D.O., Dodoo-Arhin, D., Dauda, M., Anafi, F.O., Ahmed, A.S., Ajayi, O.A., Momoh, O.J.: Crack behaviour and mechanical properties of thermally treated kaolin based ceramics: The influence of pore generating agents. Appl. Clay Sci. 194, 105698 (2020) Han, Y.S., Li, J.B., Chen, Y.J.: Fabrication of bimodal porous alumina ceramics. Mater. Res. Bull. 38(2), 373–379 (2003) Dukhan, N., Bağcı, Ö., Özdemir, M.: Experimental flow in various porous media and reconciliation of Forchheimer and Ergun relations. Exp. Thermal Fluid Sci. 57, 425–433 (2014) Liu, Q., Tang, Z., Ou, B., Liu, L., Zhou, Z., Shen, S., Duan, Y.: Design, preparation, and application of ordered porous polymer materials. Mater. Chem. Phys. 144(3), 213–225 (2014) Colombo, P.: Ceramic foams: fabrication, properties and applications. Key Eng. Mater. 206–213, 1913–1918 (2002) Li, W., Lu, K., Walz, J.Y.: Fabrication of porous nanocomposites with controllable specific surface area and strength via suspension infiltration. Langmuir 28(47), 16423–16429 (2012) Bose, S., Das, C.: Sawdust: From wood waste to pore-former in the fabrication of ceramic membrane. Ceram. Int. 41(3), 4070–4079 (2015) Simonis, J.J., Basson, A.K.: Evaluation of a low-cost ceramic micro-porous filter for elimination of common disease microorganisms. Phys. Chem. Earth, Parts A/B/C 36(14–15), 1129–1134 (2011) Nigay, P.M., Salifu, A.A., Obayemi, J.D., White, C.E., Nzihou, A., Soboyejo, W.O.: Assessment of Ceramic Water Filters for the Removal of Bacterial, Chemical, and Viral Contaminants. J. Environ. Eng. 146(7), 04020066 (2020) Chaukura, N., Chiworeso, R., Gwenzi, W., Motsa, M.M., Munzeiwa, W., Moyo, W., Nkambule, T.T.: A new generation low-cost biochar-clay composite ‘biscuit’ceramic filter for point-of-use water treatment. Appl. Clay Sci. 185, 105409 (2020) Fatimah, I., Sahroni, I., Putra, H.P., Nugraha, M.R., Hasanah, U.A.: Ceramic membrane based on TiO2-modified kaolinite as a low cost material for water filtration. Appl. Clay Sci. 118, 207–211 (2015) Efavi, J.K., Damoah, L., Bensah, D.Y., Arhin, D.D., Tetteh, D.: Development of porous ceramic bodies from kaolin deposits for industrial applications. Appl. Clay Sci. 65, 31–36 (2012) Obada, D.O., Dodoo-Arhin, D., Dauda, M., Anafi, F.O., Ahmed, A.S., Ajayi, O.A.: Potentials of fabricating porous ceramic bodies from kaolin for catalytic substrate applications. Appl. Clay Sci. 132, 194–204 (2016) Obada, D.O., Osseni, S.A., Sina, H., Salami, K.A., Oyedeji, A.N., Dodoo-Arhin, D., Bansod, N.D., Csaki, S., Atta, A.Y., Fasanya, O.O., Sowunmi, A.R., Kuburi, L.S., Dauda, M., Abifarin, J.K., Dauda, E.T.: Fabrication of novel kaolin-reinforced hydroxyapatite scaffolds with robust compressive strengths for bone regeneration. Appl. Clay Sci. 215, 106298 (2021) Liu, L., Luo, X.B., Ding, L., Luo, S.L.: Application of nanotechnology in the removal of heavy metal from water.In Nanomaterials for the removal of pollutants and resource reutilization, pp. 83–147. Elsevier (2019) Wu, T., Li, Y., Liu, G., Zhao, H., Wu, B.: Effect of Yb2O3 and Tm2O3 on the wear resistance of high-alumina ceramics. Wear 452, 203281 (2020) Nemeth, N.N., Jadaan, O.J, Gyekenyesi, J.P.: Lifetime reliability prediction of ceramic structures under transient thermomechanical loads (2005), No. E-14061. Quinn, J.B., Quinn, G.D.: A practical and systematic review of Weibull statistics for reporting strengths of dental materials. Dent. Mater. 26(2), 135–147 (2010) Muhamad, N., Abdullah, N., Rahman, M.A., Abas, K.H., Abd Aziz, A., Othman, M.H.D., Ismail, A.F.: Removal of nickel from aqueous solution using supported zeolite-Y hollow fiber membranes. Environ. Sci. Pollut. Res. 25(19), 19054–19064 (2018) Obada, D.O., Dodoo-Arhin, D., Dauda, M., Anafi, F.O., Ahmed, A.S., Ajayi, O.A., Samotu, I.A.: Physical and mechanical properties of porous kaolin based ceramics at different sintering temperatures. West Indian J. Eng, Vol.39, No.1, July 2016, pp.72–80 Sidiras, D., Batzias, F., Schroeder, E., Ranjan, R., Tsapatsis, M.: Dye adsorption on autohydrolyzed pine sawdust in batch and fixed-bed systems. Chem. Eng. J. 171(3), 883–896 (2011) Lungu, A., Perrin, F.X., Belec, L., Sarbu, A., Teodorescu, M.: Kaolin/poly (acrylic acid) composites as precursors for porous kaolin ceramics. Appl. Clay Sci. 62, 63–69 (2012) Kumar, R.V., Ghoshal, A.K., Pugazhenthi, G.: Elaboration of novel tubular ceramic membrane from inexpensive raw materials by extrusion method and its performance in microfiltration of synthetic oily wastewater treatment. J. Membr. Sci. 490, 92–102 (2015) Malik, N., Bulasara, V.K., Basu, S.: Preparation of novel porous ceramic microfiltration membranes from fly ash, kaolin and dolomite mixtures. Ceram. Int. 46(5), 6889–6898 (2020) O'Connor, P., Kleyner, A.: Practical reliability engineering. John Wiley & Sons, 5th edition, (2012) Bulta, A.L., Micheal, W.G.A.: Evaluation of the efficiency of ceramic filters for water treatment in KambataTabaro zone, southern Ethiopia. Environ. Syst. Res. 8(1), 1–15 (2019) Amlabu, B.A., Umaru, S., Dauda, M., Obada, D.O., Csaki, S., Bansod, N.D., Fasanya, O.O.: Effect of ball milling time on the physical, thermal and fracture behaviour of 2MgO.2Al2O3.5SiO2 precursors. Silicon 12(6), 1311–1324 (2020) Fangwen, L.I., Xiaoai, W.U., Songjiang, M.A., Zhongjian, X.U., Wenhua, L.I.U., Fen, L.I.U. Adsorption and desorption mechanisms of methylene blue removal with iron-oxide coated porous ceramic filter. J. Water Resour. Protect. Vol. 1 No. 1, (2009), pp. 35-40. https://doi.org/10.4236/jwarp.2009.11006 Obada, D.O., Dodoo-Arhin, D., Dauda, M., Anafi, F.O., Ahmed, A.S., Ajayi, O.A., Samotu, I.A.. Effect of mechanical activation on mullite formation in an alumina-silica ceramics system at lower temperature. World J. Eng, Vol. 13 No. 4, pp. 288–293. https://doi.org/10.1108/WJE-08-(2016)-039 Obada, D.O., Salami, K.A., Oyedeji, A.N., Fasanya, O.O., Suleiman, M.U., Ibisola, B.A., Dauda, E.T.: Solution combustion synthesis of strontium-doped hydroxyapatite: effect of sintering and low compaction pressure on the mechanical properties and physiological stability. Mater. Lett. 304, 130613 (2021) Okafor, E., Obada, D.O., Ibrahim, Y., Dodoo-Arhin, D.: Prediction of the reflection intensity of natural hydroxyapatite using generalized linear model and ensemble learning methods. Eng. Reports 3(2), e12292 (2021) Obada, D.O., Dauda, E.T., Abifarin, J.K., Dodoo-Arhin, D., Bansod, N.D.: Mechanical properties of natural hydroxyapatite using low cold compaction pressure: effect of sintering temperature. Mater. Chem. Phys. 239, 122099 (2020) Obada, D.O, Dauda, E.T, Abifarin, J.K, Bansod, N.D, Dodoo-Arhin, D.: (2020). Mechanical measurements of pure and kaolin reinforced hydroxyapatite-derived scaffolds: a comparative study. Materials Today: Proceedings, 38, 2295–2300. Akpan, E.S., Dauda, M., Kuburi, L.S., Obada, D.O., Bansod, N.D., Dodoo-Arhin, D.: (2020). Hydroxyapatite ceramics prepared from two natural sources by direct thermal conversion: From material processing to mechanical measurements. Materials Today: Proceedings, 38, 2291–2294 Akpan, E.S., Dauda, M., Kuburi, L.S., Obada, D.O., Dodoo-Arhin, D.. A comparative study of the mechanical integrity of natural hydroxyapatite scaffolds prepared from two biogenic sources using a low compaction method. Results Phys. Volme 17, June (2020). 103051. https://doi.org/10.1016/j.rinp.2020.103051 Obada, D.O, Dodoo-Arhin, D., Jimoh, A., Abdullahi, A., Bansod, N.D, Iorpenda, M.J, Ochuokpa, E.O, E.O.: The effect of acid aging on the mechanical and tribological properties of coir–coconut husk-reinforced low-density polyethylene composites. Polymer Bulletin, 78(7). 2020, 3489–3508 Obada, D.O., Kuburi, L.S., Dauda, M., Umaru, S., Dodoo-Arhin, D., Balogun, M.B., Iliyasu, I., Iorpenda, M.J.: Effect of variation in frequencies on the viscoelastic properties of coir and coconut husk powder reinforced polymer composites. J. King Saud Univ-Eng. Sci. 32(2), 148–157 (2020) Abifarin, J.K., Obada, D.O., Dauda, E.T., Dodoo-Arhin, D.: Experimental data on the characterization of hydroxyapatite synthesized from biowastes. Data Brief 26, 104485 (2019) Obada, D.O, Dauda, M., Anafi, F.O, Umaru, S., Ahmed, A.S, Ajayi, O.A, Atta, A.Y.: Characterization of zeolites as environmental washcoat materials on cordierite ceramics. 26th Int.Ocean Polar Eng. Conf. (2016), Pages 777–783 Obada, D.O., Peter, M., Kulla, D.M., Omisanya, N.O., Atta, A.Y., Dodoo-Arhin, D.: Catalytic abatement of CO species from incomplete combustion of solid fuels used in domestic cooking. Heliyon 4(8), e00748 (2018) Dodoo-Arhin, D., Nuamah, R.A., Agyei-Tuffour, B., Obada, D.O., Yaya, A.: Awaso bauxite red mud-cement based composites: characterisation for pavement applications. Case Stud Constr. Mater. 7, 45–55 (2017) Dan-Asabe, B., Yaro, A.S., Yawas, D.S., Aku, S.Y., Samotu, I.A., Abubakar, U., Obada, D.O.: Mechanical, spectroscopic and micro-structural characterization of banana particulate reinforced PVC composite as piping material. Tribol Ind 38(2), 255 (2016) Okafor, E., Obada, D.O., Dodoo-Arhin, D.: Ensemble learning prediction of transmittance at different wavenumbers in natural hydroxyapatite. Sci. Afr. 9, e00516 (2021) Hasan, M.K., Happy, M.A., Nesha, M.K., Karim, K.R.: Pollution status of Balu River due to industrial input at Dhaka, Bangladesh. Open J. Water Pollut. Treat. 1(1), 34–42 (2014)