Uniaxial tension deformation study of copper/nickel laminated composites: Effects of lamella number and interlamellar spacing

Computational Materials Science - Tập 171 - Trang 109272 - 2020
Yang Wang1, Jie Zuo1, Naisheng Jiang1, Kangmin Niu1, Ying Wu1
1School of Materials Science and Engineering, University of Science and Technology Beijing, Beijing 100083, China

Tài liệu tham khảo

Li, 2014, Highly enhanced mechanical properties in Cu matrix composites reinforced with graphene decorated metallic nanoparticles, J. Mater. Sci., 49, 3725, 10.1007/s10853-014-8082-x Niu, 2012, High-strength laminated copper matrix nanocomposites developed from a single-walled carbon nanotube film with continuous reticulate architecture, Adv. Funct. Mater., 22 Yuan, 2012, Layer thickness dependent tensile deformation mechanisms in sub-10 nm multilayer nanowires, J. Appl. Phys., 111, 10.1063/1.4730337 An, 2017, Dependence of deformation mechanisms on layer spacing in multilayered Ti/Al composite, J. Non-Cryst. Solids, 684, 491 Song, 2017, Molecular dynamics study of deformation behavior of crystalline Cu/amorphous Cu50Zr50 nanolaminates, Mater. Des., 127, 173, 10.1016/j.matdes.2017.04.077 Su, 2019, Molecular dynamics study of the tensile behaviors of Ti (0 0 0 1)/Ni (1 1 1) multilayered nanowires, Comp. Mater. Sci., 158, 149, 10.1016/j.commatsci.2018.11.019 Song, 2015, Atomic simulations of deformation mechanisms of crystalline Mg/amorphous Mg–Al nanocomposites, Phys. Lett. A, 379, 2087, 10.1016/j.physleta.2015.06.038 Song, 2018, Deformation mode transitions in Cu50Zr50 amorphous/Cu crystalline nanomultilayer: a molecular dynamics study, J. Non-Cryst. Solids, 490, 13, 10.1016/j.jnoncrysol.2018.03.036 Zhao, 2018, Deformation twinning and dislocation processes in nanotwinned copper by molecular dynamics simulations, Comp. Mater. Sci., 142, 59, 10.1016/j.commatsci.2017.09.055 Song, 2018, Atomic simulations of plastic deformation mechanism of MgAl/Mg nanoscale amorphous/crystalline multilayers, J. Non-Cryst. Solids, 500, 121, 10.1016/j.jnoncrysol.2018.06.039 Pogorelko, 2015, Influence of copper inclusions on the strength of aluminum matrix at high-rate tension, Mater. Sci. Eng. A, 642, 351, 10.1016/j.msea.2015.07.009 Cui, 2019, Design of bicontinuous metallic nanocomposites for high-strength and plasticity, Mater. Des., 166, 10.1016/j.matdes.2019.107602 Fu, 2016, Molecular dynamics simulation of effects of twin interfaces on Cu/Ni multilayers, Mater. Sci. Eng. A, 658, 1, 10.1016/j.msea.2016.01.055 Fang, 2008, Molecular dynamics simulations on nanoindentation mechanisms of multilayered films, Comp. Mater. Sci., 43, 785, 10.1016/j.commatsci.2008.01.066 Kardani, 2018, Temperature-based plastic deformation mechanism of Cu/Ag nanocomposites: a molecular dynamics study, Comp. Mater. Sci., 144, 223, 10.1016/j.commatsci.2017.12.041 Liang, 2019, Interface-coupling-dependent mechanical behaviors of sandwich-structured Ni/Cu/Ni composites, Mater. Sci. Eng. A, 743, 436, 10.1016/j.msea.2018.11.107 Jiang, 2018, A molecular dynamics based cohesive zone model for predicting interfacial properties between graphene coating and aluminum, Comp. Mater. Sci., 151, 117, 10.1016/j.commatsci.2018.05.008 Ma, 2018, Mechanical behavior of Cu-W interface systems upon tensile loading from molecular dynamics simulations, Comp. Mater. Sci., 152, 165, 10.1016/j.commatsci.2018.05.030 Kang, 2007, Bilayer thickness effects on nanoindentation behavior of Ag/Ni multilayers, Scripta Mater., 57, 703, 10.1016/j.scriptamat.2007.06.038 Niu, 2012, Size-dependent deformation mechanisms and strain-rate sensitivity in nanostructured Cu/X (X=Cr, Zr) multilayer films, Acta Mater., 60, 3677, 10.1016/j.actamat.2012.03.052 Fu, 2008, Mechanical properties of sputtered Cu/V and Al/Nb multilayer films, Mater. Sci. Eng. A, 493, 283, 10.1016/j.msea.2007.07.101 Fu, 2016, Molecular dynamics simulation of nanoindentation on Cu/Ni nanotwinned multilayer films using a spherical indenter, Sci. Rep., 6, 35665, 10.1038/srep35665 Tsakalakos, 1983, Elastic modulus in composition-modulated copper-nickel foils, J. Appl. Phys., 54, 734, 10.1063/1.332083 Tench, 1984, Enhanced tensile strength for electrodeposited nickel-copper multilayer composites, Metall. Mater. Trans. A, 15, 2039, 10.1007/BF02646838 Saraev, 2006, Atomic-scale simulations of nanoindentation-induced plasticity in copper crystals with nanometer-sized nickel coatings, Acta Mater., 54, 33, 10.1016/j.actamat.2005.08.030 Zhang, 2012, Preparation of super-hydrophobic Cu/Ni coating with micro-nano hierarchical structure, Mater. Lett., 67, 327, 10.1016/j.matlet.2011.09.114 Çölmekçi, 2019, Total film thickness controlled structural and related magnetic properties of sputtered Ni/Cu multilayer thin films, J Magn. Magn. Mater., 478, 48, 10.1016/j.jmmm.2019.01.086 Wang, 2018, Enhancing fatigue strength of high-strength ultrafine-scale Cu/Ni laminated composites, Mater. Sci. Eng. A, 714, 43, 10.1016/j.msea.2017.12.097 Tan, 2018, Toward an understanding of post-necking behavior in ultrafine-scale Cu/Ni laminated composites, Mater. Sci. Eng. A, 716, 72, 10.1016/j.msea.2018.01.028 Liu, 2011, Mechanical properties of highly textured Cu/Ni multilayers, Acta Mater., 59, 1924, 10.1016/j.actamat.2010.11.057 Weng, 2016, Strengthening effects of twin interface in Cu/Ni multilayer thin films-a molecular dynamics study, Mater. Des., 111, 1, 10.1016/j.matdes.2016.08.069 Shao, 2015, Glide dislocation nucleation from dislocation nodes at semi-coherent 1 1 1 Cu-Ni interfaces, Acta Mater., 98, 206, 10.1016/j.actamat.2015.07.044 Onat, 2013, An optimized interatomic potential for Cu–Ni alloys with the embedded-atom method, J. Phys. Condens. Mat., 26 Plimpton, 1995, Fast parallel algorithms for short-range molecular dynamics, J. Phys. Condens. Mat., 117, 1 Stukowski, 2010, Extracting dislocations and non-dislocation crystal defects from atomistic simulation data, Model. Simul. Mater. Sci. Eng., 18, 10.1088/0965-0393/18/8/085001 Tsuzuki, 2007, Structural characterization of deformed crystals by analysis of common atomic neighborhood, Comput. Phys. Commun., 177, 518, 10.1016/j.cpc.2007.05.018 He, 2018, Deformation mechanisms and ductility enhancement in core-shell Cu@Ni nanoporous metals, Comp. Mater. Sci., 150, 397, 10.1016/j.commatsci.2018.04.035 Kardani, 2018, MD-based characterization of plastic deformation in Cu/Ag nanocomposites via dislocation extraction analysis: effects of nanosized surface porosities and voids, Comp. Mater. Sci., 152, 381, 10.1016/j.commatsci.2018.06.018 Weng, 2016, Strengthening effects of twin interface in Cu/Ni multilayer thin films – a molecular dynamics study, Mater. Design, 111, 1, 10.1016/j.matdes.2016.08.069 Weng, 2019, Anisotropic and asymmetric deformation mechanisms of nanolaminated graphene/Cu composites, Nano Mater. Sci., 1, 121, 10.1016/j.nanoms.2019.02.009 Weng, 2018, Molecular dynamics study of strengthening mechanism of nanolaminated graphene/Cu composites under compression, Sci. Rep., 8, 10.1038/s41598-018-21390-1 Fu, 2019, Effects of modulation periods on mechanical properties of V/VN nano-multilayers, Ceram. Int., 45, 10295, 10.1016/j.ceramint.2019.02.084 Shao, 2015, Glide dislocation nucleation from dislocation nodes at semi-coherent 1 1 1 Cu–Ni interfaces, Acta Mater., 98, 206, 10.1016/j.actamat.2015.07.044 Shehadeh, 2007, Dislocation transmission across the Cu/Ni interface: a hybrid atomistic–continuum study, Philos. Magn., 87, 1513, 10.1080/14786430601055379 Medyanik, 2009, Strengthening effects of coherent interfaces in nanoscale metallic bilayers, Comp. Mater. Sci., 45, 1129, 10.1016/j.commatsci.2009.01.013 Ahadi, 2017, Tensile behavior of single-crystal nano-sized Cu beams–geometric scaling effects, Comp. Mater. Sci., 135, 127, 10.1016/j.commatsci.2017.04.010 Sainath, 2016, Orientation dependent deformation behaviour of BCC iron nanowires, Comp. Mater. Sci., 111, 406, 10.1016/j.commatsci.2015.09.055 Zambaldi, 2015, Orientation dependent deformation by slip and twinning in magnesium during single crystal indentation, Acta Mater., 91, 267, 10.1016/j.actamat.2015.01.046 Wu, 2006, Molecular dynamics study of the mechanics of metal nanowires at finite temperature, Eur. J. Mech. A-Solid, 25, 370, 10.1016/j.euromechsol.2005.11.008 Zhan, 2011, Numerical exploration of plastic deformation mechanisms of copper nanowires with surface defects, Comp. Mater. Sci., 50, 3425, 10.1016/j.commatsci.2011.07.004 Yan, 2018, Tensile responses of carbon nanotubes-reinforced copper nanocomposites: molecular dynamics simulation, Comp. Mater. Sci., 151, 273, 10.1016/j.commatsci.2018.05.012 Lee, 1988, On the rule of mixtures for flow stresses in stainless-steel-clad aluminium sandwich sheet metals, J. Mater. Sci., 23, 558, 10.1007/BF01174685 Zhou, 2018, Molecular dynamics simulations of tensile deformation of gradient nano-grained copper film, Comp. Mater. Sci., 142, 389, 10.1016/j.commatsci.2017.10.043 Schweitz, 2001, Hardness in Ag/Ni, Au/Ni and Cu/Ni multilayers, Philos. Mag. A, 81, 2021, 10.1080/01418610108216650 Zhu, 2015, Strengthening mechanisms of the nanolayered polycrystalline metallic multilayers assisted by twins, Int. J. Plasticity, 72, 168, 10.1016/j.ijplas.2015.05.014 Embury, 1994, On dislocation storage and the mechanical response of fine scale microstructures, Acta Metall. Mater., 42, 2051, 10.1016/0956-7151(94)90030-2 Mojumder, 2018, Molecular dynamics study of plasticity in Al-Cu alloy nanopillar due to compressive loading, Phys. B, 530, 86, 10.1016/j.physb.2017.10.119