Tổng hợp và hiệu suất của composite titania-hydroxyapatite quang xúc tác

Journal of Materials Research - Tập 23 - Trang 2398-2405 - 2008
N. Phonthammachai1, J. Kim1, T.J. White1
1School of Materials Science and Engineering, Nanyang Technological University, Singapore

Tóm tắt

Quá trình phân hủy quang xúc tác của methylene blue (MB) trên composite titania-hydroxyapatite (HAp) xốp dưới sự chiếu xạ của tia cực tím đã được nghiên cứu. Chất xúc tác được chế tạo bằng cách phủ HAp xốp bằng dung dịch titanium butoxide [Ti(OBu)4] với tỷ lệ titan dioxit từ 17–49 wt%. Phân tích nhiễu xạ tia X bột cho thấy tỉ lệ cao hơn của anatase khi nhiệt độ thiêu kết tăng từ 500 lên 800 °C do sự kết tinh của tiền chất vô định hình. Sự chuyển đổi từ anatase sang rutile bị trì hoãn đến 900 °C, cho thấy độ ổn định nhiệt cao của composite. Quá trình phân hủy HAp thành α- và β-tricalcium phosphates diễn ra ở 900 °C và đi kèm với sự hình thành perovskite ở 1000 °C. Một nghiên cứu hệ thống về ảnh hưởng của nhiệt độ thiêu kết và tỷ lệ titan dioxit:HAp cho thấy rằng với vật liệu tối ưu, diện tích bề mặt đạt được là 100 m2 g−1 tại tỷ lệ titan dioxit 49 wt% và nhiệt độ thiêu kết 600 °C. Một hệ huyền phù titania-HAp nghiền mịn phân tán cao đã tăng cường sự phân hủy quang của MB, cho phép phục hồi một tỷ lệ lớn chất xúc tác và được chứng minh là có thể tái sử dụng.

Từ khóa

#phân hủy quang xúc tác #titan dioxit #hydroxyapatite #methylene blue #thiêu kết #perovskite

Tài liệu tham khảo

C.M. Ling, A.R. Mohamed S. Bhatia: Performance of photocatalytic reactors using immobilized TiO2 film for the degradation of phenol and methylene blue dye present in water stream. Chemosphere 57, 547 2004 J. Peller, O. Wiest P.V. Kamat: Synergy of combining sonolysis and photocatalysis in the degradation and mineralization of chlorinated aromatic compounds. Environ. Sci. Technol. 37, 1926 2003 I.E. Grey N.C. Wilson: Titanium vacancy defects in sol-gel prepared anatase. J. Solid State Chem. 180, 670 2007 S.H. Lim, C. Ferraris, M. Schreyer, K. Shih, J.O. Leckie T.J. White: The influence of cobalt-doping on photocatalytic nano-titania: Crystal chemistry and amorphicity. J. Solid State Chem. 180, 2905 2007 S. Lakshmi, R. Renganathan S. Fujita: Study on TiO2-mediated photocatalytic degradation of methylene blue. J. Photochem. Photobiol., A 88, 163 1995 N.S. Figoli, C.L. Lazaroni, H.R. Keselman P.C. Largentiere: Hydrolysis of chlorobenzene over Cu-promoted hydroxyapatites. J. Catal. 77, 64 1982 Y. Matsumura, H. Kanai J.B. Moffat: Catalytic oxidation of carbon monoxide over stoichiometric and non-stoichiometric hydroxyapatites. J. Chem. Soc., Faraday Trans. 93, 4383 1997 H. Nishikawa: Thermal behavior of hydroxyapatite in structural and spectrophotometric characteristics. Mater. Lett. 50, 364 2001 H. Nishikawa: Surface changes and radical formation on hydroxyapatite by UV irradiation for inducing photocatalytic activation. J. Mol. Catal., A: Chem. 206, 331 2003 A. Nakajima, K. Takakuwa, Y. Kameshima, M. Hagiwara, S. Sato, Y. Yamamoto, N. Yoshida, T. Watanaba K. Okada: Preparation and properties of titania-apatite hybrid films. J. Photochem. Photobiol., A 177, 94 2006 J.E.G. Hulshoff, K. Van Dijk, J.P.C.M. Van der Waerden, J.G.C. Wolke, L.A. Ginsel J.A. Jansen: Biological evaluation of the effect of magnetron sputtered Ca/P coatings on osteoblast-like cells in vitro. J. Biomed. Mater. Res. 29, 967 1995 X. Nie, A. Leyland A. Matthews: Deposition of layered bioceramic hydroxyapatite/TiO2 coatings on titanium alloys using a hybrid technique of micro-arc oxidation and electrophoresis. Surf. Coat. Technol. 125, 407 2000 H. Li, K.A. Khor P. Cheang: Titanium dioxide reinforced hydroxyapatite coatings deposited by high velocity oxy-fuel (HVOF) spray. Biomaterials 23, 85 2002 P.A. Ramires, A. Romito, F. Cosentino E. Milella: The influence of titania/hydroxyapatite composite coatings on in vitro osteoblasts behaviour. Biomaterials 22, 1467 2001 A. Balamurugan, G. Balossier, S. Kannan, J. Michel S. Rajeswari: In vitro biological, chemical and electrochemical evaluation of titania reinforced hydroxyapatite sol-gel coatings on surgical grade 316L SS. Mater. Sci. Eng., C 27, 162 2007 H-W. Kim, Y-H. Koh, L-H. Li, S. Lee H-E. Kim: Hydroxyapatite and titania sol-gel composite coatings on titanium for hard tissue implants: Mechanical and in vitro biological performance. Biomaterials 25, 2533 2004 T. Zhang, T. Oyama, A. Aoshima, H. Hidaka, J. Zhao N. Serpone: Photooxidative N-demethylation of methylene blue in aqueous TiO2 dispersions under UV irradiation. J. Photochem. Photobiol., A 140, 163 2001 Z. Zainal, L.K. Hui, M.Z. Hussein, Y.H. Tanufiq-Yap, A.H. Abdullah I. Ramli: Removal of dyes using immobilized titanium dioxide illuminated by fluorescent lamps. J. Hazard. Mater. B 125, 113 2005 H. Anmin, L.L. Ming, C. Chengkang, L. Huiqin M. Dali: Preparation of nanocrystals hydroxyapatite/TiO2 compound by hydrothermal treatment. Appl. Catal., B 63, 41 2006 S.H. Lim, C. Ferraris, M. Schreyer, K. Shih, J.O. Leckie T.J. White: The influence of cobalt-doping on photocatalytic nano-titania: Crystal chemistry and amorphicity. J. Solid State Chem. 180, 2905 2007 L.M. Rodriguez-Lorenzo, J.N. Hart K.A. Gross: Structural and chemical analysis of well-crystallized hydroxyfluorapatites. J. Phys. Chem. B 107, 8316 2003 M. Horn, C.F. Schwerdtfeger E.P. Meagher: Thermal expansion of rutile and anatase. J. Am. Ceram. Soc. 53, 124 1970 J.K. Burdett, T. Hughbanks, G.J. Miller, J.W. Richardson Jr. J.V. Smith: Structural-electronic relationships in inorganic solids: Powder neutron diffraction studies of the rutile and anatase polymorphs of titanium dioxide at 15 and 295 K. J. Am. Chem. Soc. 109, 3639 1987 M. Yashima, A. Sakai, T. Kamiyama A. Hoshikawa: Crystal structure analysis of β-tricalcium phosphate Ca3(PO4)2 by neutron powder diffraction. J. Solid State Chem. 175, 272 2003 M. Mathew, L.W. Schroeder, B. Duckens W.E. Brown: The crystal structure of α-Ca3(PO4)2. Acta Crystallogr., Sect. B 33, 1325 1977 N.W. Cho, K.P. Sung S-C. Chang: Synthesis and crystal structure refinement of (1–x)CaTiO3(x)(La1/3Nd1/3)TiO3. RIST Yongu Nonmun 12, 116 1998 K.H. Yoon, J.S. Noh, C.H. Kwon M. Muhammed: Photocatalytic behavior of TiO2 thin films prepared by sol–gel process. Mater. Chem. Phys. 95, 79 2006 A.J. Patil, M.H. Potdar, S.B. Deshpande, S.R. Sainkar, S. Mayadevi S.K. Date: Chemical synthesis of titania (TiO2) powder via mixed precursor route for membrane applications. Mater. Chem. Phys. 68, 7 2001 K.S.W. Sing, D.H. Everett, R.A.W. Haul, L. Moscou, R.A. Pierotti, J. Rouquerol T. Siemieniewska: Reporting physisorption data for gas/solid systems with special reference to the determination of surface area and porosity. Pure Appl. Chem. 57, 603 1985 P. Kowalczyk, K. Kaneko, L. Solarz, A.P. Terzyk, H. Tanaka R. Holyst: Modeling of the hysteresis phenomena in finited-sized slitlike nanopores. Langmuir 21, 6613 2005 C.S. Turchi D.F. Ollis: Photocatalytic degradation of organic water contaminants: Mechanisms involving hydroxyl radical attack. J. Catal. 122, 178 1990 M. Pratap Reddy, A. Venugopal M. Subrahmanyam: Hydroxyapatite-supported Ag–TiO2 as Escherichia coli disinfection photocatalyst. Water Res. 41, 379 2007 C.G.V. Burgess, D.H. Everett S. Nuttall: Adsorption hysteresis in porous materials. Pure Appl. Chem. 61, 1845 1989 H. Nishikawa: Radical generation on hydroxyapatite by UV irradiation. Mater. Lett. 58, 14 2003 A. Houas, H. Lachheb, M. Ksibi, E. Elaloui, C. Guillard J-M. Herrmann: Photocatalytic degradation pathway of methylene blue in water. Appl. Catal., B 31, 145 2001 S. Senthilkumaar, K. Porkodi R. Vidyalakshmi: Photodegradation of a textile dye catalyzed by sol-gel derived nanocrystalline TiO2 via ultrasonic irradiation. J. Photochem. Photobiol., A 170, 225 2005 D. Chen A.K. Ray: Photocatalytic kinetics of phenol and its derivatives over UV irradiated TiO2. Appl. Catal., B 23, 143 1999 K. Nagaveni, G. Sivalingam, M.S. Hegde G. Madras: Solar photocatalytic degradation of dyes: High activity of combustion synthesized nano TiO2. Appl. Catal., B 48, 83 2004