Synthesis and Optimisation of an Integrated Renewable Energy and Greenhouse Network

Alice Godlonton1, Candice M. Borain1, Adeniyi J. Isafiade1, Klaus Möller1, Takudzwa Chitsiga1
1Department of Chemical Engineering, University of Cape Town, Cape Town, South Africa

Tóm tắt

This paper presents a study on the synthesis and optimisation of a renewable energy and resource supply chain network (SCN) to satisfy agricultural greenhouse resource and energy demands. This is motivated by the high costs and emissions to run greenhouses due to the resources and energy required for optimal growth conditions. The investigation aims to contribute to the growing area of research on circular practices in the agricultural sector. The SCN includes biomass from agricultural waste transported to a utility hub, consisting of water and carbon dioxide (CO2) as resource supplies, as well as a boiler and steam turbine-generator and solar photovoltaic (PV), as energy conversion technologies. The resources and energy are distributed to greenhouses. The objectives are to minimise both the total annualised costs (TAC) and environmental impact (EI), calculated as CO2 emissions of the integrated network. Multi-periodicity accounts for the monthly and daily variation in constraints on the system, such as feedstock and solar radiation availability and energy limitations. The model is applied to a case study of an agro-industrial zone in Kwa-Zulu Natal (KZN) province, South Africa. The network meets greenhouse demands at a minimum TAC and EI of 8.052 $$\times {10}^{6}$$ R/y and 14,370 tCO2e/y, respectively. The biomass supply chain (BSC) contributes most significantly to the TAC at 43.7% while biomass combustion makes up 99.8% of the EI. Additional key results include bagasse and corn stover being selected as the only feedstocks and rail as the transport mode. The 26,560 MWh/y of electricity supplied to the greenhouses is made up by 71.4% from the boiler and turbine-generator with the remainder from solar PV. The potential of solar PV as a clean and low-cost energy source is demonstrated by the model selection at its full capacity. The study confirms that holistic modelling and optimisation of renewable energy SCNs for greenhouses is necessary to meet a trade-off between the network costs and CO2 emissions.

Từ khóa


Tài liệu tham khảo

Abbas T, Issa M, Ilinca A (2020) Biomass cogeneration technologies: a review. J Sustain Bioenergy Syst 10:1–15. https://doi.org/10.4236/jsbs.2020.101001 AfriGIS(Pty)Ltd (2023) https://www.google.com/maps/@-29.6186485,31.0911716,4787m/data=!3m1!1e3?entry=ttu Accessed 8 Nov 2023 Ahamed MS, Guo H, Taylor L, Tanino K (2019) Heating demand and economic feasibility analysis for year-round vegetable production in Canadian Prairies greenhouses. Inf Process Agric 6:81–90. https://doi.org/10.1016/j.inpa.2018.08.005 Ahmad Fadzil F, Andiappan V, Ng DKS, Ng LY, Hamid A (2022) Sharing carbon permits in industrial symbiosis: a game theory-based optimisation model. J Clean Prod 357:131820. https://doi.org/10.1016/j.jclepro.2022.131820 Akorede MF, Hizam H, Pouresmaeil E (2010) Distributed energy resources and benefits to the environment. Renew Sustain Energy Rev 14:724–734. https://doi.org/10.1016/j.rser.2009.10.025 Babatunde A, Deborah R-A, Gan M, Simon T (2021) Economic viability of a small scale low-cost aquaponic system in South Africa. J Appl Aquac 35(2):285–304. https://doi.org/10.1080/10454438.2021.1958729 Banakar A, Montazeri M, Ghobadian B, Pasdarshahri H, Kamrani F (2021) Energy analysis and assessing heating and cooling demands of closed greenhouse in Iran. Therm Sci Eng Prog 25:101042. https://doi.org/10.1016/j.tsep.2021.101042 Coker AK (2007) Ludwig’s Applied process design for chemical and petrochemical plants, volume 1 (4th edition) - index. Elsevier. Retrieved from https://app.knovel.com/hotlink/pdf/id:kt004C16I4/ludwigs-applied-process/index Cowen N, Vogel A, Isafiade AJ, Čuček L, Kravanja Z (2019) Synthesis of combined heat exchange network and utility supply chain. Chem Eng Trans 76:391–396. https://doi.org/10.3303/CET1976066 Department of Cooperative Governance and Traditional Affairs (2010) Municipal infrastructure: an industry guide to infrastructure service delivery levels and unit costs. https://www.cogta.gov.za/mig/docs/Industry_Guide_Infrastructure_Service_Delivery_Level_and_Unit_Cost_Final.pdf Accessed 8 June 2023 Don CE, Mellet P, Ravno BD, Bodger R (1997) Calorific values of South African bagasse. Proc S Afr Sugar Technol Assoc 51:169–173 du Plessis E (2016) Evaluation and modelling of different greenhouse microclimates under South African agro-climatic conditions, MSc Thesis, School of Engineering, University of Kwa-Zulu Natal, Pietermaritzburg Dube TradePort (2022) Dube AgriZone, Dube Tradeport. https://www.dubetradeport.co.za/index.php/our-business/dube-agrizone Accessed 11 Nov 2022 EESI (2017) Fact sheet | biogas: converting waste to energy, Environmental and Energy Study Institute. https://www.eesi.org/papers/view/fact-sheet-biogasconverting-waste-to-energy. Accessed 12 Nov 2022 Egieya JM, Čuček L, Zirngast K, Isafiade AJ, Pahor B, Kravanja Z (2019) Synthesis of biogas supply networks using various biomass and manure types. Comput Chem Eng 122:129–151. https://doi.org/10.1016/j.compchemeng.2018.06.022 Egieya JM, Čuček L, Zirngast K, Isafiade AJ, Kravanja Z (2020) Optimization of biogas supply networks considering multiple objectives and auction trading prices of electricity. BMC Chem Eng 2:1–23. https://doi.org/10.1186/s42480-019-0025-5 El-Halwagi MM (2017) Steam turbines and power plants. In Sustainable design through process integration - fundamentals and applications to industrial pollution prevention, resource conservation, and profitability enhancement, 2nd ed, Elsevier https://app.knovel.com/hotlink/pdf/id:kt00A51QN1/sustainable-design-through/steam-turbines-power GAMS Development Corporation, 2014, General algebraic modeling system (GAMS) Release 24.4.6, Fairfax, VA, USA. Ghaffariyan MR, Brown M, Acuna M, Sessions J, Gallagher T, Kühmaier M, Spinelli R, Visser R, Devlin G, Eliasson L, Laitila J, Laina R, Wide MI, Egnell G (2017) An international review of the most productive and cost effective forest biomass recovery technologies and supply chains. Renew Sustain Energy Rev 74(145):158. https://doi.org/10.1016/j.rser.2017.02.014 Glaser R, Cohen B (2013) Low carbon frameworks: transport. Overview of legal and policy instruments and institutional arrangements relating to transport, land use and spatial planning in South Africa. https://wwfafrica.awsassets.panda.org/downloads/wwf_lcf_19_march_print.pdf. Accessed 8 June 2023 Golzar F, Heeren N, Hellweg S, Roshandel R (2018) A novel integrated framework to evaluate greenhouse energy demand and crop yield production. Renew Sustain Energy Rev 96:487–501. https://doi.org/10.1016/j.rser.2018.06.046 Google Maps (2022) Dube TradePort AgriHouse, KZN. Accessed 13 November 2022 <https://www.google.com/maps/place/Dube+TradePort+AgriHouse/@-29.6094106,31.0913962,17z/data=!3m1!4b1!4m5!3m4!1s0x1ef711098bd4af97:0x8775f7835d925f3b!8m2!3d-29.6094106!4d31.0935849> Gorman W, Wiser R (2019) New national lab study quantifies the cost of transmission for renewable energy | electricity markets and policy group, accessed 23 October 2022 <https://emp.lbl.gov/news/new-national-lab-study-quantifies-cost> Gxavu S, Smaill PA (2012) Design of heat exchanger networks to minimize cost and environmental impact, BSc Thesis, Department of Chemical Engineering, University of Cape Town, South Africa IEA. 2020. Capital costs of utility-scale solar PV in selected emerging economies – Charts – Data & Statistics - IEA. Accessed 20 October 2022 <https://www.iea.org/data-and-statistics/charts/capital-costs-of-utility-scale-solar-pv-in-selected-emerging-economies> Immerzeel DJ, Verweij PA, van der Hilst F, Faaij APC (2014) Biodiversity impacts of bioenergy crop production: a state-of-the-art review. GCB Bioenergy 6:183–209. https://doi.org/10.1111/gcbb.12067 IRENA (2012) Renewable energy technologies: cost analysis series biomass for power generation. International Renewable Energy Agency. https://www.irena.org/-/media/Files/IRENA/Agency/Publication/2012/RE_Technologies_Cost_Analysis-BIOMASS.pdf?rev=a38db79e0352425aad35a7f06eef7726. Accessed 8 June 2023 Isafiade AJ, Short M (2022) Multi-objective optimisation of integrated renewable energy feedstock supply chain and work-heat exchanger network synthesis considering economics and environmental impact, Chemical Engineering Transactions. Chem Eng Trans 94:1123–1128. https://doi.org/10.3303/CET2294187 Kibirige B (2018) Monthly average daily solar radiation simulation in northern KwaZulu-Natal: a physical approach. S Afr J Sci 114(9–10):1–8. https://doi.org/10.17159/sajs.2018/4452 Koelsch R (2018) What is the economic value of beef manure, Institute of Agriculture and Natural Resources, University of Nebraska Lincoln. https://beef.unl.edu/beefwatch/what-economic-value-beef-manure. Accessed 12 Nov 2022 Lee CG, Cho LH, Kim SJ, Park SY, Kim DH (2021) Comparative analysis of combined heating systems involving the use of renewable energy for greenhouse heating. Energies 14(20):6603. https://doi.org/10.3390/en14206603 LPELC Admin (2019) What are typical values for the higher heating value of manure scraped from cattle feedyard surfaces? Livestock and Poultry Environmental Learning Community. https://lpelc.org/what-are-typical-values-for-the-higher-heating-value-of-manure-scraped-from-cattle-feedyard-surfaces. Accessed 8 June 2023 McFadyen S (2013) Photovoltaic (PV) - electrical calculations, My Electrical Engineering. https://myelectrical.com/notes/entryid/225/photovoltaic-pv-electrical-calculations. Accessed 12 Nov 2022 Mohlala LM, Bodunrin MO, Awosusi AA, Daramola MO, Cele NP, Olubambi PA (2016) Beneficiation of corncob and sugarcane bagasse for energy generation and materials development in Nigeria and South Africa: a short overview. Alex Eng J 55(3):3025–3036 Mosey G, Supple L (2021) Renewable energy for heat & power generation and energy storage in greenhouses, National Renewable Energy Laboratory, Joint Institute for Strategic Energy Analysis. https://www.nrel.gov/docs/fy21osti/80382.pdf. Accessed 8 June 2023 Murat Yazan D, Yazdanpanah V, Fraccascia L, Engineering M, Ruberti A (2020) Learning strategic cooperative behavior in industrial symbiosis: a game-theoretic approach integrated with agent-based simulation. Bus Strateg Environ 29(5):2078–2091. https://doi.org/10.1002/bse.2488 Mutenure M, Čuček L, Egieya J, Isafiade AJ, Kravanja Z (2018) Optimization of bioethanol and sugar supply chain network: a South African case study. Clean Technol Environ Policy 20:925–948. https://doi.org/10.1007/s10098-018-1535-1 Neves A, Godina R, Azevedo SG, Pimentel C, Matias JCO (2019) The potential of industrial symbiosis: case analysis and main drivers and barriers to its implementation. Sustainability (switzerland) 11:7095. https://doi.org/10.3390/su11247095 Nikolaou G, Neocleous D, Christou A, Polycarpou P, Kitta E, Katsoulas N (2021) Energy and water related parameters in tomato and cucumber greenhouse crops in semiarid Mediterranean regions A Review, Part i: Increasing Energy Efficiency. Horticulture 7:521. https://doi.org/10.3390/horticulturae7120521 Ouammi A (2021) Model predictive control for optimal energy management of connected cluster of microgrids with net zero energy multi-greenhouses. Energy 234:121274. https://doi.org/10.1016/j.energy.2021.121274 Priarone A, Fossa M, Paietta E, Rolando D (2017) Energy demand hourly simulations and energy saving strategies in greenhouses for the Mediterranean climate. J Phys: Conf Ser 796:012027. https://doi.org/10.1088/1742-6596/796/1/012027 Rafiq MK, Bachmann RT, Rafiq MT, Shang Z, Joseph S, Long RL (2016) Influence of pyrolysis temperature on physico-chemical properties of corn stover (zea mays l.) biochar and feasibility for carbon capture and energy balance. PLoS ONE 11(6):e0156894. https://doi.org/10.1371/journal.pone.0156894 Ren Z, Dong Y, Lin D, Zhang L, Fan Y, Xia X (2022) Managing energy-water-carbon-food nexus for cleaner agricultural greenhouse production: a control system approach. Sci Total Environ 848:157756. https://doi.org/10.1016/j.scitotenv.2022.157756 Rice DCJ, Carriveau R, Ting DSK, Bata MH (2017) Evaluation of crop to crop water demand forecasting: tomatoes and bell peppers grown in a commercial greenhouse. Agriculture (switzerland) 7(12):104. https://doi.org/10.3390/agriculture7120104 Runkle E (2011) Greenhouse energy conservation strategies, https://rucore.libraries.rutgers.edu/rutgers-lib/47310/PDF/1/play/. Accessed 23 May 2023 Segen (2020) Solar panels | monocrystalline or polycrystalline (PV panels) – Segen Solar (Pty) Ltd. https://segensolar.co.za/solar-panels/. Accessed 20 Oct 2022 Shenoy UV (1995) Heat exchanger network synthesis: process optimization by energy and resource analysis. Gulf Publishing Company, Houston, Texas, USA, pp 419–419 Su Y, Xu L, Goodman ED (2021) Multi-layer hierarchical optimisation of greenhouse climate setpoints for energy conservation and improvement of crop yield. Biosys Eng 205:212–233. https://doi.org/10.1016/j.biosystemseng.2021.03.004 Svarc J (2022) Most efficient solar panels 2022 — clean energy reviews. <https://www.cleanenergyreviews.info/blog/most-efficient-solar-panels. Accessed 20 Oct 2022 Szkutnik-Rogoż J, Ziółkowski J, Małachowski J, Oszczypała M (2021) Mathematical programming and solution approaches for transportation optimisation in supply network. Energies 14(21):7010. https://doi.org/10.3390/en14217010 Taki M, Rohani A, Rahmati-Joneidabad M (2018) Solar thermal simulation and applications in greenhouse. Inf Process Agric 5:83–113. https://doi.org/10.1016/j.inpa.2017.10.003 You F, Wang B (2011) Life cycle optimization of biomass-to-liquid supply chains with distributed-centralized processing networks. Ind Eng Chem Res 50(17):10102–10127. https://doi.org/10.1021/ie200850t Zhao X, Xue Y, Ding L (2020) Implementation of low carbon industrial symbiosis systems under financial constraint and environmental regulations: an evolutionary game approach. J Clean Prod 277:124289. https://doi.org/10.1016/j.jclepro.2020.1242