Production of activated carbon derived from agricultural by-products via microwave-induced chemical activation: a review
Tóm tắt
Từ khóa
Tài liệu tham khảo
Özhan A, Şahin Ö, Küçük MM, Saka C (2014) Preparation and characterization of activated carbon from pine cone by microwave-induced ZnCl2 activation and its effects on the adsorption of methylene blue. Cellulose 21(4):2457–2467
Ahmad A, Hameed B (2009) Reduction of COD and color of dyeing effluent from a cotton textile mill by adsorption onto bamboo-based activated carbon. J Hazard Mater 172(2–3):1538–1543
Ahmad A, Hameed B (2010) Fixed-bed adsorption of reactive azo dye onto granular activated carbon prepared from waste. J Hazard Mater 175(1–3):298–303
Ahmad A, Hameed B, Ahmad A (2009) Removal of disperse dye from aqueous solution using waste-derived activated carbon: optimization study. J Hazard Mater 170(2–3):612–619
Ahmad A, Hameed B, Aziz N (2007) Adsorption of direct dye on palm ash: kinetic and equilibrium modeling. J Hazard Mater 141(1):70–76
Ahmad A, Idris A (2014) Preparation and characterization of activated carbons derived from bio-solid: a review. Desalin Water Treat 52(25–27):4848–4862
Ahmed MJ (2016) Application of agriculturally based activated carbons by microwave and conventional activations for basic dye adsorption. J Environ Chem Eng 4(1):89–99
Ali A, Idris R (2016) Utilization of low-cost activated carbon from rapid synthesis of microwave pyrolysis for WC nanoparticles preparation. Adv Mater Lett 8(1):70–76
Alslaibi TM, Abustan I, Ahmad MA, Foul AA (2013) A review: production of activated carbon from agricultural byproducts via conventional and microwave heating. J Chem Technol Biotechnol 88(7):1183–1190
Andrew N, Bella R, Thomas V (2003) Responding to global demands for sustainable palm oil: industry-WWF collaboration. Paper presented at the Proceedings of the international planter’s conference
Ania C, Parra J, Menendez J, Pis J (2005) Effect of microwave and conventional regeneration on the microporous and mesoporous network and on the adsorptive capacity of activated carbons. Microporous Mesoporous Mater 85(1–2):7–15
Ao W, Fu J, Mao X, Kang Q, Ran C, Liu Y, Zhang H, Gao Z, Li J, Liu G (2018) Microwave assisted preparation of activated carbon from biomass: a review. Renew Sustain Energy Rev 92:958–979
Ben-Iwo J, Manovic V, Longhurst P (2016) Biomass resources and biofuels potential for the production of transportation fuels in Nigeria. Renew Sustain Energy Rev 63:172–192
Chen C, Zhao P, Li Z, Tong Z (2016) Adsorption behavior of chromium (VI) on activated carbon from eucalyptus sawdust prepared by microwave-assisted activation with ZnCl2. Desalin Water Treat 57(27):12572–12584
Cheng S, Zhang L, Xia H, Zhang S, Peng J, Wang S (2016) Crofton weed derived activated carbon by microwave-induced KOH activation and application to wastewater treatment. J Porous Mater 23(6):1597–1607
Deng H, Li G, Yang H, Tang J, Tang J (2010) Preparation of activated carbons from cotton stalk by microwave assisted KOH and K2CO3 activation. Chem Eng J 163(3):373–381
Deng H, Li G, Yang H, Tang J, Tang J (2011) Preparation of activated carbons from cotton stalk by microwave assisted KOH and K2CO3 activation. Chem Eng J 163(3):373–381
Deng H, Yang L, Tao G, Dai J (2009) Preparation and characterization of activated carbon from cotton stalk by microwave assisted chemical activation—application in methylene blue adsorption from aqueous solution. J Hazard Mater 166(2–3):1514–1521
Djebabra D, Dessaux O, Goudmand P (1991) Coal gasification by microwave plasma in water vapour. Fuel 70(12):1473–1475
Dominguez A, Menendez J, Fernandez Y, Pis J, Nabais JV, Carrott P, Carrott MR (2007) Conventional and microwave induced pyrolysis of coffee hulls for the production of a hydrogen rich fuel gas. J Anal Appl Pyrolysis 79(1–2):128–135
Du C, Yang H, Wu Z, Ge X, Cravotto G, Ye B-C, Kaleem I (2016) Microwave-assisted preparation of almond shell-based activated carbon for methylene blue adsorption. Green Process Synth 5(4):395–406
Elsayed M, Zalat O (2015) Factor affecting microwave assisted preparation of activated carbon from local raw materials. Int Lett Chem Phys Astron 47:15–23
Foo K, Hameed B (2009) Utilization of biodiesel waste as a renewable resource for activated carbon: application to environmental problems. Renew Sustain Energy Rev 13(9):2495–2504
Foo K, Hameed B (2010) Factors affecting the carbon yield and adsorption capability of the mangosteen peel activated carbon prepared by microwave assisted K2CO3 activation. Chem Eng J 180:66–74
Foo K, Hameed B (2011) Microwave-assisted preparation of oil palm fiber activated carbon for methylene blue adsorption. Chem Eng J 166(2):792–795
Foo K, Hameed B (2011) Microwave assisted preparation of activated carbon from pomelo skin for the removal of anionic and cationic dyes. Chem Eng J 173(2):385–390
Foo K, Hameed B (2011) Preparation and characterization of activated carbon from pistachio nut shells via microwave-induced chemical activation. Biomass Bioenerg 35(7):3257–3261
Foo K, Hameed B (2011) Preparation and characterization of activated carbon from sunflower seed oil residue via microwave assisted K2CO3 activation. Bioresour Technol 102(20):9794–9799
Foo K, Hameed B (2011) Preparation of activated carbon from date stones by microwave induced chemical activation: application for methylene blue adsorption. Chem Eng J 170(1):338–341
Foo K, Hameed B (2011) Preparation of oil palm (Elaeis) empty fruit bunch activated carbon by microwave-assisted KOH activation for the adsorption of methylene blue. Desalination 275(1–3):302–305
Foo K, Hameed B (2011) Utilization of rice husks as a feedstock for preparation of activated carbon by microwave induced KOH and K2CO3 activation. Bioresour Technol 102(20):9814–9817
Foo K, Hameed B (2012) Coconut husk derived activated carbon via microwave induced activation: effects of activation agents, preparation parameters and adsorption performance. Chem Eng J 184:57–65
Foo K, Hameed B (2012) Factors affecting the carbon yield and adsorption capability of the mangosteen peel activated carbon prepared by microwave assisted K2CO3 activation. Chem Eng J 180:66–74
Foo K, Hameed B (2012) Mesoporous activated carbon from wood sawdust by K2CO3 activation using microwave heating. Bioresour Technol 111:425–432
Foo K, Hameed B (2012) Microwave-assisted preparation and adsorption performance of activated carbon from biodiesel industry solid reside: influence of operational parameters. Bioresour Technol 103(1):398–404
Foo K, Hameed B (2012) Porous structure and adsorptive properties of pineapple peel based activated carbons prepared via microwave assisted KOH and K2CO3 activation. Microporous Mesoporous Mater 148(1):191–195
Foo K, Hameed B (2012) Potential of jackfruit peel as precursor for activated carbon prepared by microwave induced NaOH activation. Bioresour Technol 112:143–150
Foo K, Hameed B (2012) Preparation, characterization and evaluation of adsorptive properties of orange peel based activated carbon via microwave induced K2CO3 activation. Bioresour Technol 104:679–686
Foo K, Hameed B (2012) Textural porosity, surface chemistry and adsorptive properties of durian shell derived activated carbon prepared by microwave assisted NaOH activation. Chem Eng J 187:53–62
Freeman HM (1995) Industrial pollution prevention handbook. McGraw-Hill, New York
Fu YC, Blaustein BD, Sharkey A Jr (1972) Reaction of coal with nitrogen in a microwave discharge. Fuel 51(4):308–311
Gadkari S, Fidalgo B, Gu S (2017) Numerical investigation of microwave-assisted pyrolysis of lignin. Fuel Process Technol 156:473–484
Gan C, Liu Y, Tan X, Wang S, Zeng G, Zheng B, Li T, Jiang Z, Liu W (2015) Effect of porous zinc–biochar nanocomposites on Cr (VI) adsorption from aqueous solution. RSC Adv 5(44):35107–35115
Gorka J, Zawislak A, Choma J, Jaroniec M (2008) KOH activation of mesoporous carbons obtained by soft-templating. Carbon 46(8):1159–1161
Guo J, Lua AC (2000) Preparation of activated carbons from oil-palm-stone chars by microwave-induced carbon dioxide activation. Carbon 38(14):1985–1993
Guo J, Xu WS, Chen YL, Lua AC (2005) Adsorption of NH3 onto activated carbon prepared from palm shells impregnated with H2SO4. J Colloid Interface Sci 281(2):285–290
Gurrath M, Kuretzky T, Boehm H, Okhlopkova L, Lisitsyn A, Likholobov V (2000) Palladium catalysts on activated carbon supports: influence of reduction temperature, origin of the support and pretreatments of the carbon surface. Carbon 38(8):1241–1255
Hameed B, Ahmad A (2009) Batch adsorption of methylene blue from aqueous solution by garlic peel, an agricultural waste biomass. J Hazard Mater 164(2–3):870–875
He X, Ling P, Qiu J, Yu M, Zhang X, Yu C, Zheng M (2013) Efficient preparation of biomass-based mesoporous carbons for supercapacitors with both high energy density and high-power density. J Power Sources 240:109–113
Henning K-D, SchÃfer S (1993) Impregnated activated carbon for environmental protection. Gas Sep Purif 7(4):235–240
Hernández M, González M (2002) Synthesis of resins as alpha-alumina precursors by the Pechini method using microwave and infrared heating. J Eur Ceram Soc 22(16):2861–2868
Hesas RH, Arami-Niya A, Daud WMAW, Sahu J (2013) Preparation and characterization of activated carbon from apple waste by microwave-assisted phosphoric acid activation: application in methylene blue adsorption. BioResources 8(2):2950–2966
Hesas RH, Daud WMAW, Sahu J, Arami-Niya A (2013) The effects of a microwave heating method on the production of activated carbon from agricultural waste: a review. J Anal Appl Pyrolysis 100:1–11
Hirata M, Kawasaki N, Nakamura T, Matsumoto K, Kabayama M, Tamura T, Tanada S (2002) Adsorption of dyes onto carbonaceous materials produced from coffee grounds by microwave treatment. J Colloid Interface Sci 254(1):17–22
Huang L, Sun Y, Wang W, Yue Q, Yang T (2011) Comparative study on characterization of activated carbons prepared by microwave and conventional heating methods and application in removal of oxytetracycline (OTC). Chem Eng J 171(3):1446–1453
Huang Y, Li S, Lin H, Chen J (2014) Fabrication and characterization of mesoporous activated carbon from Lemna minor using one-step H3PO4 activation for Pb (II) removal. Appl Surf Sci 317:422–431
Imamoglu M, Tekir O (2008) Removal of copper (II) and lead (II) ions from aqueous solutions by adsorption on activated carbon from a new precursor hazelnut husk. Desalination 228(1–3):108–113
Indarto A, Palguandi J (2012) Syngas: production, applications, and environmental impact. Nova Science Publishers, Incorporated
Izquierdo M, Rubio B, Mayoral C, Andres J (2001) Modifications to the surface chemistry of low-rank coal-based carbon catalysts to improve flue gas nitric oxide removal. Appl Catal B 33(4):315–324
Ji Y, Li T, Zhu L, Wang X, Lin Q (2007) Preparation of activated carbons by microwave heating KOH activation. Appl Surf Sci 254(2):506–512
JonesDA LT, Mavrofidis S, Kingman S, Miles N (2002) Microwave heating applications in environmental engineering—a review. Resour Conserv Recycl 34(2):75–90
Langmuir I (1918) The adsorption of gases on plane surfaces of glass, mica and platinum. J Am Chem Soc 40(9):1361–1403
Li W, Zhang L-b, Peng J-h, Li N, Zhu X-y (2008) Preparation of high surface area activated carbons from tobacco stems with K2CO3 activation using microwave radiation. Ind Crops Prod 27(3):341–347
Lillo-Ródenas M, Cazorla-Amorós D, Linares-Solano A (2003) Understanding chemical reactions between carbons and NaOH and KOH: an insight into the chemical activation mechanism. Carbon 41(2):267–275
Liou T-H (2010) Development of mesoporous structure and high adsorption capacity of biomass-based activated carbon by phosphoric acid and zinc chloride activation. Chem Eng J 158(2):129–142
Liu C, Chen W, Hong S, Pan M, Jiang M, Wu Q, Mei C (2019) Fast microwave synthesis of hierarchical porous carbons from waste palm boosted by activated carbons for supercapacitors. Nanomaterials 9(3):405
Liu P, Wu Z, Ge X, Yang X (2019) Hydrothermal synthesis and microwave-assisted activation of starch-derived carbons as an effective adsorbent for naphthalene removal. RSC Adv 9(21):11696–11706
Liu Q-S, Zheng T, Li N, Wang P, Abulikemu G (2010) Modification of bamboo-based activated carbon using microwave radiation and its effects on the adsorption of methylene blue. Appl Surf Sci 256(10):3309–3315
Liu Q-S, Zheng T, Wang P, Guo L (2010) Preparation and characterization of activated carbon from bamboo by microwave-induced phosphoric acid activation. Ind Crops Prod 31(2):233–238
Lu A, Zhang S, Shan X-q, Wang S, Wang Z (2003) Application of microwave extraction for the evaluation of bioavailability of rare earth elements in soils. Chemosphere 53(9):1067–1075
Martí Rosselló T, Li J, Lue L (2016) Kinetic models for biomass pyrolysis. Arch Ind Biotechnol 1(1):4–7
Mazyck DW, Cannon FS (2000) Overcoming calcium catalysis during the thermal reactivation of granular activated carbon: Part I. Steam-curing plus ramped-temperature N2 treatment. Carbon 38(13):1785–1799
Nabais JV, Carrott P, Carrott MR, Menéndez J (2004) Preparation and modification of activated carbon fibres by microwave heating. Carbon 42(7):1315–1320
Nieto-Delgado C, Terrones M, Rangel-Mendez J (2011) Development of highly microporous activated carbon from the alcoholic beverage industry organic by-products. Biomass Bioenerg 35(1):103–112
Nowicki P, Skrzypczak M, Pietrzak R (2010) Effect of activation method on the physicochemical properties and NO2 removal abilities of sorbents obtained from plum stones (Prunus domestica). Chem Eng J 162(2):723–729
Oghbaei M, Mirzaee O (2010) Microwave versus conventional sintering: A review of fundamentals, advantages and applications. J Alloy Compd 494(1–2):175–189
Olivares-Marín M, Fernández-González C, Macías-García A, Gómez-Serrano V (2006) Thermal behaviour of lignocellulosic material in the presence of phosphoric acid. Influence of the acid content in the initial solution. Carbon (New York, NY) 44(11):2347–2350
Quesada-Peñate I, Julcour-Lebigue C, Jáuregui-Haza U-J, Wilhelm A-M, Delmas H (2009) Comparative adsorption of levodopa from aqueous solution on different activated carbons. Chem Eng J 152(1):183–188
Raymundo-Pinero E, Azaïs P, Cacciaguerra T, Cazorla-Amorós D, Linares-Solano A, Beguin F (2005) KOH and NaOH activation mechanisms of multiwalled carbon nanotubes with different structural organisation. Carbon 43(4):786–795
Sharif YM, Saka C, Baytar O, Şahin Ö (2018) Preparation and characterization of activated carbon from sesame seed shells by microwave and conventional heating with zinc chloride activation. Anal Lett 51(17):2733–2746
Tay T, Ucar S, Karagöz S (2009) Preparation and characterization of activated carbon from waste biomass. J Hazard Mater 165(1–3):481–485
Ukanwa KS, Patchigolla K, Sakrabani R, Anthony E, Mandavgane S (2019) A review of chemicals to produce activated carbon from agricultural waste biomass. Sustainability 11(22):6204
Villota EM, Lei H, Qian M, Yang Z, Villota SMA, Zhang Y, Yadavalli G (2018) Optimizing microwave-assisted pyrolysis of phosphoric acid-activated biomass: impact of concentration on heating rate and carbonization time. ACS Sustain Chem Eng 6(1):1318–1326
Walker G, Weatherley L (2000) Textile wastewater treatment using granular activated carbon adsorption in fixed beds. Sep Sci Technol 35(9):1329–1341
Wang T, Tan S, Liang C (2009) Preparation and characterization of activated carbon from wood via microwave-induced ZnCl2 activation. Carbon 47(7):1880–1883
Wen Q, Li C, Cai Z, Zhang W, Gao H, Chen L, Zeng G, Shu X, Zhao Y (2011) Study on activated carbon derived from sewage sludge for adsorption of gaseous formaldehyde. Bioresour Technol 102(2):942–947
Yagmur E, Ozmak M, Aktas Z (2008) A novel method for production of activated carbon from waste tea by chemical activation with microwave energy. Fuel 87(15–16):3278–3285
Yang J, Qiu K (2010) Preparation of activated carbons from walnut shells via vacuum chemical activation and their application for methylene blue removal. Chem Eng J 165(1):209–217
Yao Z, Ji X, Sarker P, Tang J, Ge L, Xia M, Xi Y (2015) A comprehensive review on the applications of coal fly ash. Earth Sci Rev 141:105–121
Yorgun S, Vural N, Demiral H (2009) Preparation of high-surface area activated carbons from Paulownia wood by ZnCl2 activation. Microporous Mesoporous Mater 122(1–3):189–194
Yuen FK, Hameed B (2009) Recent developments in the preparation and regeneration of activated carbons by microwaves. Adv Colloid Interface Sci 149(1–2):19–27
Zhang Z, Qu W, Peng J, Zhang L, Ma X, Zhang Z, Li W (2009) Comparison between microwave and conventional thermal reactivations of spent activated carbon generated from vinyl acetate synthesis. Desalination 249(1):247–252
Zhong Z-Y, Yang Q, Li X-M, Luo K, Liu Y, Zeng G-M (2012) Preparation of peanut hull-based activated carbon by microwave-induced phosphoric acid activation and its application in Remazol Brilliant Blue R adsorption. Ind Crops Prod 37(1):178–185