Process intensification of SO2/CO2 co-capture using microscale vortex flow contactor: Mass transfer behaviors, performance modeling, and flow simulation

Ahmed, 2020, Recent advances in carbon-based renewable adsorbent for selective carbon dioxide capture and separation-A review, J. Clean. Prod., 242, 118409, 10.1016/j.jclepro.2019.118409 Bernardo, 2006, 3-D computational fluid dynamics for gas and gas-particle flows in a cyclone with different inlet section angles, Powder Technol., 162, 190, 10.1016/j.powtec.2005.11.007 Bizzo, W.A., Sadala, R.A., Hory, R.I., Pecora, A.A.B., 2003. Experimental study of SO2 absorption in a cyclone scrubber, Proceedings of COBEM 1877. Bogodage, 2016, Improvements of the cyclone separator performance by down-comer tubes, J. Hazard. Mat., 311, 100, 10.1016/j.jhazmat.2016.02.072 Cao, 2007, Experimental research of hydrocyclone for gas absorption, Chin. J. Environ. Eng., 1, 102 Chen, 2020, Enhanced performance on simultaneous removal of NOx-SO2-CO2 using a high-gravity rotating packed bed and alkaline wastes towards green process intensification, Chem. Eng. J., 393, 124678, 10.1016/j.cej.2020.124678 Chen, 2011, Correlations of mass transfer coefficients in a rotating packed bed, Ind. Eng. Chem. Res., 50, 1778, 10.1021/ie101251z Chuah, 2006, A CFD study of the effect cone dimensions on sampling aerocyclones performance and hydrodynamics, Powder Technol., 162, 126, 10.1016/j.powtec.2005.12.010 Danckwerts, 1955, Gas absorption accompanied by chemical reaction, AIChE J., 1, 456, 10.1002/aic.690010412 Gao, 2019, A novel gas-solids separator scheme of coupling cyclone with circulating granular bed filter (C-CGBF), J. Hazard. Mat., 362, 403, 10.1016/j.jhazmat.2018.07.065 Hura, H.S., Diehl, R.C., 1994. Acid gas removal in a confined vortex scrubber. United States, Dec 1994. CONF-940930-TRN: IM9521 361. https://www.osti.gov/biblio/43195-acid-gas-removal-confined-vortex-scrubber. Javed, 2010, The CO2 capture performance of a high-intensity vortex spray scrubber, Chem. Eng. J., 162, 448, 10.1016/j.cej.2010.03.038 Javed, 2006, Enhancement of mass transfer in a spray using swirling gas flow, Chem. Eng. Res. Des., 84, 465, 10.1205/cherd.05119 Kittiampon, 2017, Carbon dioxide absorption using ammonia solution in a microchannel, Int. J. Greenh. Gas Control, 63, 431, 10.1016/j.ijggc.2017.06.014 Mariana, 2004, Experimental and modeling study on CO2 absorption in a cyclone scrubber by phenomenological model and neural networks, Korean, J. Chem. Eng., 21, 589 Misiak, 2013, Next Generation Post-combustion Capture: Combined CO2 and SO2 Removal, Energy Procedia, 37, 1150, 10.1016/j.egypro.2013.05.212 Pan, 2020, Simultaneous removal of CO2 and H2S from coalbed methane in a membrane contactor, J. Clean. Prod., 273, 123107, 10.1016/j.jclepro.2020.123107 Parvaz, 2020, Influence of the dipleg shape on the performance of gas cyclones, Sep. Purif. Technol., 233, 116000, 10.1016/j.seppur.2019.116000 Pourmohammadbagher, 2011, Simultaneous removal of gaseous pollutants with a novel swirl wet scrubber, Chem. Eng. Proc., 50, 773, 10.1016/j.cep.2011.06.001 Qi, 2015, Mass transfer and kinetics study on combined CO2 and SO2 absorption using aqueous ammonia, Int. J. Greenh. Gas Control, 41, 60, 10.1016/j.ijggc.2015.06.023 Quan, 2009, Air stripping of ammonia in a water-sparged aerocyclone reactor, J. Hazard. Mater., 170, 983, 10.1016/j.jhazmat.2009.05.083 Schrauwen, 1988, Selective gas absorption in a cyclone spray scrubber, Chem. Eng. Sci., 43, 2189, 10.1016/0009-2509(88)87102-1 Sepehri, 2018, Effect of nitrifiers community on fouling mitigation and nitrification efficiency in a membrane bioreactor, Chem. Eng. Proc.-Proc. Intensif., 128, 10, 10.1016/j.cep.2018.04.006 Sohaib, 2020, CO2 capture with room temperature ionic liquids; coupled absorption/desorption and single module absorption in membrane contactor, Chem. Eng. Sci., 223, 115719, 10.1016/j.ces.2020.115719 Spector, 1946, Removal of carbon dioxide from atmospheric air, Am. Inst. Chem. Eng. Trans., 42, 827 Taheri, 2021, Ionic liquid screening for CO2 capture and H2S removal from gases: The syngas purification case, Chem. Eng. Sci., 230, 116199, 10.1016/j.ces.2020.116199 Tope, 1943, Absorption of carbon dioxide by sodium hydroxide solutions in a packed column, Am. Inst. Chem. Eng. Trans., 39, 255 Wang, 2020, Wet flue gas desulfurization using micro vortex flow scrubber: Characteristics, modeling and simulation, Sep. Purif. Technol., 247, 116915, 10.1016/j.seppur.2020.116915 Wang, 2017, Application of gas cyclone-liquid jet absorption separator for flue-gas desulfurization, Aerosol Air Qual. Res., 17, 2705, 10.4209/aaqr.2016.12.0574 Whitman, 1923, The two-film theory of gas absorption, Chem. Metal. Eng., 29, 146 Yang, 2013, Effect of the inlet dimensions on the maximum-efficiency cyclone height, Sep. Purif. Technol., 105, 15, 10.1016/j.seppur.2012.12.020 Yu, 2015, Mass transfer performance of enhanced CO2 absorption in swirling flow field, J. Chem. Ind. Eng. Soc. China, 66, 1012 Zhao, 2016, Post-combustion CO2 capture with ammonia by vortex flow-based multistage spraying: Process intensification and performance characteristics, Energy, 102, 106, 10.1016/j.energy.2016.02.056 Zhao, 2012, Post-combustion CO2 capture by aqueous ammonia: A state-of-the-art review, Int. J. Greenh. Gas Control, 9, 355, 10.1016/j.ijggc.2012.05.006 Zhao, 2013, Mass transfer characteristics and mechanism in a water-sparged aerocyclone, J. Chem. Ind. Eng. Soc. China, 64, 3652 Zhao, 2013, Wet desulfurization of flue gas and mass transfer mechanism in water-sparged aerocyclone, J. Chem. Ind. Eng. Soc. China, 64, 3993 Zhao, 2015, Intensification and mechanism of gas-liquid mass transfer in water-sparged aerocyclone by microparticles, J. Chem. Ind. Eng. Soc. China, 66, 3866 Zhou, 2016, Flue gas desulfurization research in liquid jet-absorption coupled gas cyclone-separation device, Chem. Ind. Eng. Prog., 35, 4053