Modeling of the oxy-combustion calciner in the post-combustion calcium looping process

Metz B, Davidson O, de Coninck H, Loos M, Meyer L. Special report on carbon dioxide capture and storage. In: Intergovernmental panel on climate change. Cambridge (UK): Cambridge University Press; 2005. McCauley, 2009, Commercialization of oxy-coal combustion: applying results of a large 30MWth pilot project, Energy Procedia, 1, 439, 10.1016/j.egypro.2009.01.059 Shimizu, 1999, A twin fluid-bed reactor for removal of CO2 from combustion processes, Chem Eng Res Des, 77, 62, 10.1205/026387699525882 Anthony, 2008, Solid looping cycles: a new technology for coal conversion, Ind Eng Chem Res, 47, 1747, 10.1021/ie071310u Rodriguez, 2011, Experimental investigation of a circulating fluidized-bed reactor to capture CO2 with CaO, AICHE J, 57, 1356, 10.1002/aic.12337 Sánchez-Biezma, 2011, Postcombustion CO2 capture with CaO. Status of the technology and next steps towards large scale demonstration, Energy Procedia, 4, 852, 10.1016/j.egypro.2011.01.129 Hawthorne C, Trossmann M, Cifre PG, Schuster A, Scheffknecht G. Simulation of the carbonate looping power cycle. In: Proceedings of the 9th international conference on Greenhouse Gas Control Technologies (GHGT-9), 16–20 November 2008, Washington, DC, USA. Energy Procedia 2009;1:1387–1394. Alonso, 2009, Modelling of a fluidized bed carbonator reactor to capture CO2 from a combustion flue gas, Chem Eng Sci, 64, 883, 10.1016/j.ces.2008.10.044 Romano, 2012, Modeling the carbonator of a Ca-looping process for CO2 capture from power plant flue gas, Chem Eng Sci, 69, 257, 10.1016/j.ces.2011.10.041 Lasheras, 2011, Carbonate looping process simulation using a 1D fluidized bed model for the carbonator, Int J Greenhouse Gas Control, 5, 686, 10.1016/j.ijggc.2011.01.005 Ylätalo, 2012, 1-Dimensional modeling and simulation of the calcium looping process, Int J Greenhouse Gas Control, 9, 130, 10.1016/j.ijggc.2012.03.008 Baker, 1962, The calcium oxide–carbon dioxide system in the pressure range of 1–300 atmospheres, J Chem Soc, 70, 464, 10.1039/JR9620000464 Silcox, 1989, A mathematical model for the flash calcination of dispersed CaCO3 and Ca(OH)2 particles, Ind Eng Chem Res, 28, 155, 10.1021/ie00086a005 García-Labiano, 2002, Calcination of calcium based sorbents at pressure in a broad range of CO2 concentrations, Chem Eng Sci, 57, 2381, 10.1016/S0009-2509(02)00137-9 Martínez, 2012, Kinetics of calcination of partially carbonated particles in a Ca-looping system for CO2 capture, Energy Fuels, 26, 1432, 10.1021/ef201525k Takkinen, 2012, Heat and mass transfer in calcination of limestone particles, AICHE J, 58, 2563, 10.1002/aic.12774 Takkinen, 2011, Experimental and modeling study of sulfur capture by limestone in selected conditions of air-fired and oxy-fuel circulating fluidized-bed boilers, Energy Fuels, 25, 2968, 10.1021/ef200416e Fang, 2009, Experiment and modeling of CO2 capture from flue gases at high temperature in a fluidized bed reactor with Ca-based sorbents, Energy Fuels, 23, 207, 10.1021/ef800474n Dennis, 1987, The effect of CO2 on the kinetics and extent of calcination of limestone and dolomite particles in fluidized beds, Chem Eng Sci, 42, 2361, 10.1016/0009-2509(87)80110-0 González, 2010, Sorbent attrition in a carbonation/calcination pilot plant for capturing CO2 from flue gases, Fuel, 89, 2918, 10.1016/j.fuel.2010.01.019 Rodríguez, 2010, Average activity of CaO particles in a calcium looping system, Chem Eng J, 156, 388, 10.1016/j.cej.2009.10.055 Johnsson F, Leckner B. Vertical distribution of solids in a CFB-furnace. In: Heinschel K, editor. In: Proceedings of the 13th international conference on fluidized bed combustion, Orlando, FL, USA, May 07–10, 1995. p. 671–9. Basu P. Combustion and gasification in fluidized beds. 2006. ISBN-0849333962. De-Souza Santos, 2010 Yetter RA, Dryer FL, Rabitz H. Complications of one-step kinetics for moist CO oxidation. In: Proceedings 21st symposium (international) on combustion. Combustion Institute; 1986. p. 749–60. Vilienskii, 1978, Dynamics of the combustion of pulverized fuel, Energia (Moscow), 11, 246 Branch MC, Sawyer RF. Ammonia oxidation kinetics in an arc heated flow reactor. In: Proc 14th symposium (international) on combustion, Pittsburgh, PA, 1973. p. 967–74. Leveson PD. Kinetic studies to determine the rates of ammonia and hydrogen sulphide destruction under claus plant operating conditions, PhD thesis. University of Sheffield, Department of Chemical Engineering and Fuel Technology, Sheffield (United Kingdom); 1997. Quan V, Marble FE, Klingel JR. In: Proc. 14th symposium (International) on combustion, Pittsburgh, PA, August 20–25, 1972, p. 851–60. Myöhänen K. Modelling of combustion and sorbent reactions in three-dimensional flow environment of a circulating fluidized bed furnace. dissertation; 2011. Lappeenranta. ISBN 978-952-265-160-0. Myöhänen K, Hyppänen T. A three-dimensional model frame for modelling combustion and gasification in circulating fluidized bed furnaces. Int J Chem React Eng. 2011; 9: [Article A25]. Han, 2005, Effect of characteristics of calcium-based sorbents on the sulfation kinetics, Fuel, 84, 1933, 10.1016/j.fuel.2005.04.001 Mattisson, 1998, A sulphur capture model for circulating fluidized-bed boilers, Chem Eng Sci, 53, 1163, 10.1016/S0009-2509(97)00448-X Liu, 2000, Sulfation behavior of limestone under high CO2 concentration in O2/CO2 coal combustion, Fuel, 79, 945, 10.1016/S0016-2361(99)00212-4 Hu, 2008, Initial kinetics of the direct sulfation of limestone, AICHE, 54, 2663, 10.1002/aic.11570