Experimental study on explosive mechanism of spontaneous combustion gangue dump
Tóm tắt
In order to explore the reason for the frequency explosion of spontaneous combustion coal gangue dump and get to know their explosion mechanism, established the experiment platform about spontaneous combustion coal gangue dump interoperable water. The gangue dump was heated using the external heat source, and rainy weather through water mist was simulated. Simulated experiment about explosion of spontaneous combustion coal gangue dump was carried out on the different conditions of the rainfall or not. The unusual gases produced in the course of gangue combustion and the changes in temperature were observed, and their impacts on the explosion of gangue dump were analyzed. The experimental results show that overall warming phenomenon of the gangue dump after watering occurred, the amount of H2 is three times than that before watering, and the amount of CO is far greater than that on the conditions of no-watering, at the same time combining with local observation and tests. It is found that the content of the oxygen reduce with the temperature increasing; however, gangue dump internal hydrogen content increase unusually on the rainfall conditions at 90°C, but the local measuring points reach the explosion limit. The existence of the CO and H2 is the main reason for inducing the explosion of spontaneous combustion coal gangue dump.
Tài liệu tham khảo
Hao J S, Wei G Y, Liu Q X, 2005. Characteristics of coal quality and Geochemical in Jiaozuo Coal Basin. Journal of Henan Polytechnic University (Natural Science Edition), 24(3): 192–195.
Jia B S, Zhang Q F, Sun F Y, 2003. Prevention and control measure for spontaneous combustion of coal gangue dump. Journal of Liaoning Technology University (Natural Science Edition), 22(4): 512–513.
Jiang A L, 2000. The composition characteristics and the of utilization channels of gangne. China Coal, 26(3): 25–27.
Pan R K, Yu M G, Xu J, Huang Z, 2006. Harm of gangue dump and Cause analysis of spontaneous combustion. Safety and Environmental Engineering, 13(2): 66–69.
Pan R K, Yu M G, 2007. Harm of spontaneous combustion gangue dump explosion and its prevention techniques. Journal of Henan Polytechnic University(Natural Science Edition), 26(5): 484–488.
State Economic and Trade Commission, Science and Technology Headquarter, 2000. Announce the gangue comprehensive utilization technology policy essential combined. Clean coal technology, (1): 56.
Yang G Q, Liu K H, 2000. Solid waste disposal project. Beijing: Science Press, 112–138.
Zhang Z W, Song Z, Li A H, 2001. Analysis of gangue hill spontaneous combustion and its affecting factors. Journal of Heilongjiang Institute of Science, 11(2): 12–14.
Zhang Z W, 2002. Forming mechanism and influence factors of gangue hill spray explosion. Journal of Liaoning Technology University, 21(1): 11–14.