Enhanced Electrical Conductivity and Dielectric Performance of Ternary Nanocomposite Film of PEMA/PS/Silver NPs Synthesized by Laser Ablation
Tóm tắt
The synthesis of ternary nanocomposites with tailored properties based on polymer blends is gaining popularity all over the world. Our work introduces a novel ternary nanocomposite of poly (ethylmethacrylate)/polystyrene/silver nanoparticles (PEMA/PS/Ag NPs). Silver nanoparticles were synthesized via laser ablation route at different laser times (5, 10, 15, 20, and 30 min) and scattered in PEMA/PS blend in one step. The prepared Ag NPs@PEMA/PS films were investigated via FT-IR, XRD, SEM, and UV-Vis. techniques. The dielectric characterization and electrical conductivity of the prepared have been performed. FT-IR results approve the particular interaction in NPs@PEMA/PS at various laser ablation times. XRD results showed an increase in amorphousity, which encouraged the interaction between Ag NPs and the PEMA/PS blend. SEM photo reveals that the scattering of Ag NPs has been raised on the surfaces of the samples as the concentration of Ag NPs increased in the PEMA/PS matrix. The optical properties of the synthesized samples obtain a distinct absorption peak at 432 nm that has been attributed to Ag NPs surface plasmon resonance (SPR). The energy gap of prepared samples decreased as the concentration of Ag NPs in PEMA/PS increased, decreasing from 3.64 to 2.71 eV for the direct transition and from 1.68 to 0.42 eV for the indirect transition. The dielectric constant, dielectric loss, and A.C electrical conductivity of Ag NPs@PEMA/PS films increased with increasing in Ag NPs content. The PEMA/PS/Ag NPs at laser ablation time 30 min achieves a maximum ionic conductivity of ~ 7.86 × 10–5 S/cm. The results confirm that NPs@PEMA/PS films nanocomposites have excellent optical and electronic properties, which may encourage the application of these composites in different electric and optoelectric utilization.
Từ khóa
Tài liệu tham khảo
X. Li, X. Yang, D. Yi, B. Liu, J. Zhu, J. Li, L. Wang, Effects of NbC content on microstructural evolution and mechanical properties of laser cladded Fe50Mn30Co10Cr10-xNbC composite coatings. Intermetallics 138, 107309 (2021)
X. Li, D. Yi, X. Wu, J. Zhang, X. Yang, Z. Zhao, Y. Liu, Effect of construction angles on microstructure and mechanical properties of AlSi10Mg alloy fabricated by selective laser melting. J. Alloy. Compd. 881, 160459 (2021)
X. Bai, C. Li, L. Dong, Q. Yin, Experimental evaluation of the lubrication performances of different nanofluids for minimum quantity lubrication (MQL) in milling Ti–6Al–4V. Int. J. Adv. Manuf. Technol. 101(9), 2621–2632 (2019)
D. Jia, C. Li, D. Zhang, Y. Zhang, X. Zhang, Experimental verification of nanoparticle jet minimum quantity lubrication effectiveness in grinding. J. Nanopart. Res. 16(12), 1–15 (2014)
J.Q. Almarashi, M.H. Abdel-Kader, Exploring nano-sulfide enhancements on the optical, structural and thermal properties of polymeric nanocomposites. J. Inorg. Organomet. Polym. Mater. 30(8), 3230–3240 (2020)
X. Chen, B. Jiang, D. Wang, G. Li, H. Wang, H. Wang, Z. Wei, Gate-tunable the interface properties of GaAs–WSe2 (1D–2D) vdWs heterojunction for high-responsivity, self-powered photodetector. Appl. Phys. Lett. 118(4), 041102 (2021)
Y. Huang, C. An, Q. Zhang, L. Zang, H. Shao, Y. Liu, Y. Wang, Cost-effective mechanochemical synthesis of highly dispersed supported transition metal catalysts for hydrogen storage. Nano Energy 80, 105535 (2021)
H. Li, J. Tang, Y. Kang, H. Zhao, D. Fang, X. Fang, Z. Wei, Optical properties of quasi-type-II structure in GaAs/GaAsSb/GaAs coaxial single quantum-well nanowires. Appl. Phys. Lett. 113(23), 233104 (2018)
W. Zhu, M. Deng, D. Chen, Z. Zhang, W. Chai, D. Chen, Y. Hao, Dual-phase CsPbCl3–Cs4PbCl6 perovskite films for self-powered, visible-blind UV photodetectors with fast response. ACS Appl. Mater. Interfaces 12(29), 32961–32969 (2020)
P. Wisian-Neilson, H. Truong, J.H. Jung, Poly (alkyl/arylphosphazene)-metal nanoparticle composites. J. Inorg. Organomet. Polym. Mater. 30(1), 259–267 (2020)
S. Hussein, A. Abd-Elnaiem, N. Ali, A. Mebed, Enhanced thermo-mechanical properties of poly (vinyl alcohol)/poly (vinyl pyrrolidone) polymer blended with nanographene. Curr. Nanosci. 16(6), 994–1001 (2020)
A.A. Al-Shamari, A.M. Abdelghany, H. Alnattar, A.H. Oraby, Structural and optical properties of PEO/CMC polymer blend modified with gold nanoparticles synthesized by laser ablation in water. J. Market. Res. 12, 1597–1605 (2021)
N.A. Ali, S.I. Hussein, T.B. Asafa, A.M. Abd-Elnaiem, Mechanical properties and electrical conductivity of poly (methyl methacrylate)/multi-walled carbon nanotubes composites. Iran. J. Sci. Technol. Trans. A 44(5), 1567–1576 (2020)
T. Watanabe, K. Karita, M. Manabe, T. Ono, Preparation of monodisperse poly (methyl methacrylate)/polystyrene composite particles by seeded emulsion polymerization using a sequential flow process. Front. Chem. Eng. 62, 1–8 (2021)
A.Y. Yassin, A.M. Abdelghani, M.M. Shaban, Y.M. Abdallah, Synthesis, characterization and electrochemical behavior for API 5L X70 carbon steel in 5% sulfamic acid medium using PVVH/PEMA blend filled with gold nanoparticles. Colloids Surf. A 635, 128115 (2021)
C.V. More, P.P. Pawar, M.S. Badawi, A.A. Thabet, Extensive theoretical study of gamma-ray shielding parameters using epoxy resin-metal chloride mixtures. Nucl. Technol. Radiat. Prot. 35(2), 138–149 (2020)
Y. Chen, Y. Wang, Synthesis and characterization of hollow mesoporous silica spheres using negative-charged polystyrene particles as templates. J. Inorg. Organomet. Polym. Mater. 27(1), 380–384 (2017)
A.M. Ismail, R.A. Nasr, Structural characterization of PVDF/PVA polymer blend film doped with different concentration of NiO NPs for photocatalytic degradation of malachite green dye under visible light. J. Appl. Polym. Sci. 8, 51847 (2021)
N.H. El Fewaty, A.M. El Sayed, R.S. Hafez, Synthesis, structural and optical properties of tin oxide nanoparticles and its CMC/PEG–PVA nanocomposite films. Polym. Sci. Ser. A 58(6), 1004–1016 (2016)
M. Goikoetxea, I. Amenabar, S. Chimenti, M. Paulis, J.R. Leiza, R. Hillenbrand, Cross-sectional chemical nanoimaging of composite polymer nanoparticles by infrared nanospectroscopy. Macromolecules 54(2), 995–1005 (2021)
A. Bekhoukh, I. Moulefera, L. Sabantina, B. Abdelghani, Development, investigation, and comparative study of the effects of various metal oxides on optical electrochemical properties using a doped PANI matrix. Polymers 13(19), 3344 (2021)
B. Ji, F. Zhang, X. Song, Y. Tang, A novel potassium-ion-based dual-ion battery. Adv. Mater. 29(19), 1700519 (2017)
X. Zhang, Y. Tang, F. Zhang, C.S. Lee, A novel aluminum–graphite dual-ion battery. Adv. Energy Mater. 6(11), 1502588 (2016)
Y. Wang, C. Li, Y. Zhang, M. Yang, B. Li, D. Jia, C. Mao, Experimental evaluation of the lubrication properties of the wheel/workpiece interface in minimum quantity lubrication (MQL) grinding using different types of vegetable oils. J. Clean. Prod. 127, 487–499 (2016)
S. Guo, C. Li, Y. Zhang, Y. Wang, B. Li, M. Yang, G. Liu, Experimental evaluation of the lubrication performance of mixtures of castor oil with other vegetable oils in MQL grinding of nickel-based alloy. J. Clean. Prod. 140, 1060–1076 (2017)
Z. Lu, F.Y. Zhang, H. Fu, H. Ding, L.Q. Chen, Rotational nonlinear double-beam energy harvesting. Smart Mater. Struct. 31(2), 025020 (2021)
J. Zhang, C. Li, Y. Zhang, M. Yang, D. Jia, G. Liu, H. Cao, Experimental assessment of an environmentally friendly grinding process using nanofluid minimum quantity lubrication with cryogenic air. J. Clean. Prod. 193, 236–248 (2018)
B. Li, C. Li, Y. Zhang, Y. Wang, D. Jia, M. Yang, K. Sun, Heat transfer performance of MQL grinding with different nanofluids for Ni-based alloys using vegetable oil. J. Clean. Prod. 154, 1–11 (2017)
S.J. Young, Y.H. Liu, Z.D. Lin, K. Ahmed, M.N.I. Shiblee, S. Romanuik, A. Khosla, Multi-walled carbon nanotubes decorated with silver nanoparticles for acetone gas sensing at room temperature. J. Electrochem. Soc. 167(16), 167519 (2020)
G. Bagherzade, M.M. Tavakoli, M.H. Namaei, Green synthesis of silver nanoparticles using aqueous extract of saffron (Crocus sativus L.) wastages and its antibacterial activity against six bacteria. Asian Pacif. J. Trop. Biomed. 7(3), 227–233 (2017)
A. Singh, A. Ahmed, A. Sharma, C. Sharma, S. Paul, A. Khosla, S. Arya, Promising photocatalytic degradation of methyl orange dye via sol-gel synthesized Ag–CdS@ Pr–TiO2 core/shell nanoparticles. Physica B 616, 413121 (2021)
M. Bhagat, S. Rajput, S. Arya, S. Khan, P. Lehana, Biological and electrical properties of biosynthesized silver nanoparticles. Bull. Mater. Sci. 38(5), 1253–1258 (2015)
S. Arya, A. Singh, R. Kour, Comparative study of CuO, CuO@ Ag and CuO@ Ag: La nanoparticles for their photosensing properties. Mater. Res. Express 6(11), 116313 (2019)
A.M. Mostafa, Preparation and study of nonlinear response of embedding ZnO nanoparticles in PVA thin film by pulsed laser ablation. J. Mol. Struct. 1223, 129007 (2021)
Z. Wang, B. Xiao, Z. Lin, S. Shen, A. Xu, Z. Du, W. Zhong, In-situ surface decoration of RuO2 nanoparticles by laser ablation for improved oxygen evolution reaction activity in both acid and alkali solutions. J. Energy Chem. 54, 510–518 (2021)
A.M. Mostafa, E.A. Mwafy, A. Toghan, ZnO nanoparticles decorated carbon nanotubes via pulsed laser ablation method for degradation of methylene blue dyes. Colloids Surf. A 627, 127204 (2021)
A.A. Menazea, Femtosecond laser ablation-assisted synthesis of silver nanoparticles in organic and inorganic liquids medium and their antibacterial efficiency. Radiat. Phys. Chem. 168, 108616 (2020)
E.H. Alsharaeh, Polystyrene-poly (methyl methacrylate) silver nanocomposites: Significant modification of the thermal and electrical properties by microwave irradiation. Materials 9(6), 458 (2016)
H.G. Xu, M.C. Qu, Y.M. Pan, D.W. Schubert, Conductivity of poly (methyl methacrylate)/polystyrene/carbon black and poly (ethyl methacrylate)/polystyrene/carbon black ternary composite films. Chin. J. Polym. Sci. 38(3), 288–297 (2020)
S. Jayanthi, G.P. Kokila, S. Shenbagavalli, B. Sundaresan, Preparation and characterization of novel potassium ion conducting nanocomposite polymer electrolytes based on PEMA. J. Elastomers Plast. (2021). https://doi.org/10.1177/00952443211038661
A. Sachdeva, S. Singh, P.K. Singh, Effect of incorporation of zinc oxide nanoparticles on properties of PEMA based polymer electrolyte. Mater. Today 34, 697–701 (2021)
A.M. Ismail, M.H. El-Newehy, M.E. El-Naggar, A.M. Moydeen, A.A. Menazea, Enhancment the electrical conductivity of the synthesized polyvinylidene fluoride/polyvinyl chloride composite doped with palladium nanoparticles via laser ablation. J. Market. Res. 9(5), 11178–11188 (2020)
A.S. El-Bayoumi, Influence of the gamma radiation on the structure of PVDF/PANI blend. J. Inorg. Organomet. Polym. Mater. 30(3), 613–621 (2020)
Z.J. Sweah, A.J. Mohammed, Preparation and study of mechanical and thermal properties of polymer blends from recycled materials of polystyrene and polymethylmethacryalate with different ratio of diethylmalonate. J. Glob. Sci. Res. 4, 466–476 (2020)
A.M. Abdelghany, A.H. Oraby, M.O. Farea, Influence of green synthesized gold nanoparticles on the structural, optical, electrical and dielectric properties of (PVP/SA) blend. Physica B 560, 162–173 (2019)
J.C. Joo, G.Y. Kim, C.H. Ahn, S. Lee, J.R. Park, J.K. Kim, Development of titanium dioxide (TiO2)-embedded buoyant photocatalyst balls using expanded polystyrene. J. Nanosci. Nanotechnol. 19(2), 1065–1068 (2019)
M.O. Farea, A.M. Abdelghany, A.H. Oraby, Optical and dielectric characteristics of polyethylene oxide/sodium alginate-modified gold nanocomposites. RSC Adv. 10(62), 37621–37630 (2020)
A.M. Abdelghany, M.O. Farea, A.H. Oraby, Structural, optical, and electrical reinforcement of gamma-irradiated PEO/SA/Au NPs nanocomposite. J. Mater. Sci. 32(5), 6538–6549 (2021)
A.M. Abdelghany, G. El-Damrawi, A.G. ElShahawy, N.M. Altomy, Structural investigation of PVC/PS polymer blend doped with nanosilica from a renewable source. SILICON 10(3), 1013–1019 (2018)
A.G. Adeniyi, S.A. Abdulkareem, J.O. Ighalo, D.V. Onifade, S.A. Adeoye, A.E. Sampson, Morphological and thermal properties of polystyrene composite reinforced with biochar from elephant grass (Pennisetum purpureum). J. Thermoplast. Compos. Mater. (2020). https://doi.org/10.1177/0892705720939169
A.A. Menazea, M.K. Ahmed, Nanosecond laser ablation assisted the enhancement of antibacterial activity of copper oxide nano particles embedded though polyethylene oxide/polyvinyl pyrrolidone blend matrix. Radiat. Phys. Chem. 174, 108911 (2020)
A.A. Menazea, A.M. Abdelghany, Precipitation of silver nanoparticle within silicate glassy matrix via Nd: YAG laser for biomedical applications. Radiat. Phys. Chem. 174, 108958 (2020)
M. Abdelaziz, M.M. Ghannam, Influence of titanium chloride addition on the optical and dielectric properties of PVA films. Physica B 405(3), 958–964 (2010)
A.M. Abdelghany, M.S. Mekhail, E.M. Abdelrazek, M.M. Aboud, Combined DFT/FT-IR structural studies of monodispersed PVP/Gold and silver nano particles. J. Alloy. Compd. 646, 326–332 (2015)
E.M. Abdelrazek, A.M. Abdelghany, A.E. Tarabiah, H.M. Zidan, AC conductivity and dielectric characteristics of PVA/PVP nanocomposite filled with MWCNTs. J. Mater. Sci. 30(16), 15521–15533 (2019)
M. Ram, S. Chakrabarti, Dielectric and modulus behavior of LiFe1/2Ni1/2VO4 ceramics. J. Phys. Chem. Solids 69(4), 905–912 (2008)
R. Ranjan, R. Kumar, N. Kumar, B. Behera, R.N.P. Choudhary, Impedance and electric modulus analysis of Sm-modified Pb (Zr0.55Ti0.45)1–x/4O3 ceramics. J. Alloys Compd. 509(22), 6388–6394 (2011)
A.A. Al-Muntaser, A.M. Abdelghany, E.M. Abdelrazek, A.G. Elshahawy, Enhancement of optical and electrical properties of PVC/PMMA blend films doped with Li4Ti5O12 nanoparticles. J. Market. Res. 9(1), 789–797 (2020)
M.S. Meikhail, A.H. Oraby, M.M. El-Nahass, H.M. Zeyada, A.A. Al-Muntaser, Electrical conduction mechanism and dielectric characterization of MnTPPCl thin films. Physica B 539, 1–7 (2018)
S.R. Elliott, Ac conduction in amorphous chalcogenide and pnictide semiconductors. Adv. Phys. 36(2), 135–217 (1987)
A.R. Long, Frequency-dependent loss in amorphous semiconductors. Adv. Phys. 31(5), 553–637 (1982)
M. Robinson, J.A. Pask, D.W. Fuerstenau, Surface charge of alumina and magnesia in aqueous media. J. Am. Ceram. Soc. 47(10), 516–520 (1964)
R.J. Sengwa, S. Choudhary, S. Sankhla, Dielectric properties of montmorillonite clay filled poly (vinyl alcohol)/poly (ethylene oxide) blend nanocomposites. Compos. Sci. Technol. 70(11), 1621–1627 (2010)
E.M. Abdelrazek, I.S. Elashmawi, A.M. Hezma, A. Rajeh, M. Kamal, Effect of an encapsulate carbon nanotubes (CNTs) on structural and electrical properties of PU/PVC nanocomposites. Physica B 502, 48–55 (2016)
C.V. Chanmal, J.P. Jog, Dielectric relaxations in PVDF/BaTiO3 nanocomposites. Express. Polym. Lett. 2(4), 294–301 (2008)
M.K. Mishra, S. Moharana, B. Dash, R.N. Mahaling, Effect of poly (ethylene glycol) on the dielectric properties of poly (vinylidene fluoride)/BiFeO3/poly (ethylene glycol) composite films for electronic applications. Polym. Sci. Ser. A 59(1), 133–142 (2017)