Effect of the initial pH on the anaerobic digestion process of dairy cattle manure
Tóm tắt
Anaerobic digestion (AD) has recently been studied to obtain products of greater interest than biogas, such as volatile fatty acids (VFAs) and phytoregulators. The effect of the initial pH of cow manure and the fermentation time of the AD on the microbial composition, VFAs, indole-3-acetic acid (IAA) and gibberellic acid (GA3) production was evaluated. The cow manure (7% solids) was adjusted to initial pH values of 5.5, 6.5, 7.5, and 8.5, and the AD products were analyzed every four days until day 20. The initial pH and the fermentation time had an important effect on the production of metabolites. During AD, only the hydrolytic and acidogenic stages were identified, and the bacteria found were from the phyla Firmicutes, Bacteroidetes, Actinobacteria, and Spirochaetes. The most abundant genera produced in the four AD were Caproiciproducens, Clostridium sensu stricto 1, Romboutsia, Paeniclostridium, Turicibacter, Peptostreptococcaceae, Ruminococcaceae and Fonticella. The highest amount of VFAs was obtained at pH 8.5, and the production of the acids was butyric > acetic > propionic. The maximum production of GA3 and IAA was at an initial pH of 6.5 on day 20 and a pH of 5.5 on day 4, respectively. There was a strong correlation (> 0.8) between the most abundant microorganisms and the production of VFAs and GA3. The anaerobic digestion of cow manure is a good alternative for the production of VFAs, GA3 and IAA.
Tài liệu tham khảo
APHA (2017) Standard methods for the examination of water and wastewater, 23rd edn. American Public Health Association, Washington DC
Bermúdez-Penabad N, Kennes C, Veiga MC (2017) Anaerobic digestion of tuna waste for the production of volatile fatty acids. Waste Manag 68:96–102. https://doi.org/10.1016/j.wasman.2017.06.010
Bolyen E, Rideout JR, Dillon MR, Bokulich NA, Abnet CC, Al-Ghalith GA, Alexander H, Alm EJ et al (2019) Reproducible, interactive, scalable and extensible microbiome data science using QIIME 2. Nat Biotechnol 37:852–857. https://doi.org/10.1038/s41587-019-0209-9
Castro-Ramos JJ, Castro-Rivera R, Solís-Oba MM, Osorio-Cortes G, Romero-Rodríguez A, Juárez-Rangel AP (2021) Perenial ryegrass (Lolium perenne L.) yield as a response to fitoregulators produced in digestates. Agroproductividad. 14(2):3–8
Dai G, Chen X, He Y (2021) The gut microbiota activates AhR through the tryptophan metabolite Kyn to mediate renal cell carcinoma metastasis. Front Nutr 8:712327. https://doi.org/10.3389/fnut.2021.712327
Duarte AC, Holman DB, Alexander TW, Durmic Z, Vercoe PE, Chaves AV (2017) The type of forage substrate preparation included as substrate in a RUSITEC system affects the ruminal microbiota and fermentation characteristics. Front Microbiol 8:704. https://doi.org/10.3389/fmicb.2017.00704
Greses S, Tomás-Pejó E, Gónzalez-Fernández C (2020) Agroindustrial waste as a resource for volatile fatty acids production via anaerobic fermentation. Bioresour Technol 297:122486. https://doi.org/10.1016/j.biortech.2019.122486
Huang L, Chen Z, Xiong D, Wen Q, Ji Y (2018) Oriented acidification of wasted activated sludge (WAS) focused on odd-carbon volatile fatty acid (VFA): regulation strategy and microbial community dynamics. Water Res 142:256–266. https://doi.org/10.1016/j.watres.2018.05.062
Huang X, Zhao J, Xu Q, Li X, Wang D, Yang Q, Liu Y, Tao Z (2019) Enhanced volatile fatty acids production from waste activated sludge anaerobic fermentation by adding tofu residue. Bioresour Technol 274:430–438. https://doi.org/10.1016/j.biortech.2018.12.010
Jomnonkhaow U, Uwineza C, Mahboubi A, Wainaina S, Reungsang A, Taherzadeh MJ (2021) Membrane bioreactor-assisted volatile fatty acids production and in situ recovery from cow manure. Bioresour Technol 321:124456. https://doi.org/10.1016/j.biortech.2020.124456
Karishma S, Arya MS, Reshma UR, Anaswara SJ, Thampi SS (2019) Impact of plant growth regulators on fruit production. Int J Curr Microbiol App Sci 8:800–814. https://doi.org/10.20546/ijcmas.2019.802.092
Khatami K, Atasoy M, Ludtke M, Baresel C, Eyice O, Cetecioglu Z (2021) Bioconversion of food waste to volatile fatty acids: impact of microbial community, pH and retention time. Chemosphere. 275:129981. https://doi.org/10.1016/j.chemosphere.2021.129981
Li X, Guo J, Pang C, Dong R (2016) Anaerobic digestion and storage influence availability of plant hormones in livestock slurry. ACS Sustain Chem Eng 4:719–727. https://doi.org/10.1021/acssuschemeng.5b00586
Li Y, Zhao J, Krooneman J, Jan G, Euverink W (2021) Strategies to boost anaerobic digestion performance of cow manure: laboratory achievements and their full-scale application potential. Sci Total Environ 755:142940. https://doi.org/10.1016/j.scitotenv.2020.142940
Li B-Y, Xia Z-Y, Gou M, Sun Z-Y, Huang Y-L, Jiao S-B, Dai W-Y, Tang Y-Q (2022) Production of volatile fatty acid from fruit waste by anaerobic digestion at high organic loading rates: performance and microbial community characteristics. Bioresour Technol 346:126648. https://doi.org/10.1016/j.biortech.2021.126648
Lin L, Li X (2018) Effects of pH adjustment on the hydrolysis of Al-enhanced primary sedimentation sludge for volatile fatty acid production. Chem Eng J 346:50–56. https://doi.org/10.1016/J.CEJ.2018.04.005
Ludwig-Müller J, Cohen JD (2002) Identification and quantification of three active auxins in different tissues of Tropaeolum majus. Physiol Plant 115:320–329. https://doi.org/10.1034/j.1399-3054.2002.1150220.x
Nguyen LN, Nguyen AQ, Johir MAH, Guo W, Ngo HH, Chaves AV, Nghiem LD (2019) Application of rumen and anaerobic sludge microbes for bio harvesting from lignocellulosic biomass. Chemosphere 228:702–708. https://doi.org/10.1016/j.chemosphere.2019.04.159
Nzeteu C, Joyce A, Thorn C, McDonnell K, Shirran S, O’Flaherty V, Abram F (2021) Resource recovery from the anaerobic digestion of food waste is underpinned by cross-kingdom microbial activities. Bioresour Technol Rep 16:100847. https://doi.org/10.1016/j.biteb.2021.100847
Oliveira J, Rodrigues C, Vandenberghe LPS, Camara MC, Libardi N, Soccol CR (2017) Gibberellic acid production by different fermentation systems using citric pulp as substrate/support. BioMed Res Int. https://doi.org/10.1155/2017/5191046
Peng X, Zhang S, Li L, Zhao X, Ma Y, Shi D (2018) Long-term high-solids anaerobic digestion of food waste: effects of ammonia on process performance and microbial community. Bioresour Technol 262:148–158. https://doi.org/10.1016/j.biortech.2018.04.076
Pervez MN, Bilgiç B, Mahboubi A, Uwineza C, Zarra T, Belgiorno V, Naddeo V, Taherzadeh MJ (2022) Double-stage membrane-assisted anaerobic digestion process intensification for production and recovery of volatile fatty acids from food waste. Sci Total Environ 825:154084. https://doi.org/10.1016/j.scitotenv.2022.154084
Pokusaeva K, Fitzgerald GF, van Sinderen D (2011) Carbohydrate metabolism in Bifidobacteria. Genes Nutr 6:285–306. https://doi.org/10.1007/s12263-010-0206-6
Pore SD, Shetty D, Arora P, Maheshwari S, Dhakephalkar PK (2016) Metagenome changes in the biogas producing community during anaerobic digestion of rice straw. Biores Technol 213:50–53. https://doi.org/10.1016/j.biortech.2016.03.045
Quast C, Pruesse E, Yilmaz P, Gerken J, Schweer T, Yarza P, Peplies J, Glöckner FO (2013) The SILVA ribosomal RNA gene database project: improved data processing and web-based tools. Nucl Acids Res 41:D590–D596. https://doi.org/10.1093/nar/gks1219
Scaglia B, Pognani M, Adani F (2015) Evaluation of hormone-like activity of the dissolved organic matter fraction (DOM) of compost and digestate. Sci Total Environ 514:314–321. https://doi.org/10.1016/j.scitotenv.2015.02.009
Scaglia B, Pognani M, Adani F (2017) The anaerobic digestion process capability to produce biostimulant: the case study of the dissolved organic matter (DOM) vs auxin-like property. Sci Total Environ 589:36–45. https://doi.org/10.1016/j.scitotenv.2017.02.223
Shukla R, Srivastava AK, Chand S (2003) Bioprocess strategies and recovery process in gibberellic acid fermention. Biotechnol Bioprocess Eng 8:269–278. https://doi.org/10.1007/BF02949216
Siddikee MA, Hamayun M, Han GH, Sa T (2010) Optimization of gibberellic acid production by Methylobacterium oryzae CBMB20. Korean J Soil Sci Fert 43:522–527
Sträuber H, Schröder M, Kleinsteuber S (2012) Metabolic and microbial community dynamics during the hydrolytic and acidogenic fermentation in a leach-bed process. Energ Sustain Soc 2:13. https://doi.org/10.1186/2192-0567-2-13
Suksong W, Kongjan P, Prasertsan P, O-Thong S (2019) Thermotolerant cellulolytic Clostridiaceae and Lachnospiraceae rich consortium enhanced biogas production from oil palm empty fruit bunches by solid-state anaerobic digestion. Biores Technol 291:121851. https://doi.org/10.1016/j.biortech.2019.121851
Teniza-García O, Solís-Oba MM, Pérez-López ME, González-Prieto JM, Valencia-Vázquez R (2015) Producción de metano utilizando residuos cunícolas. Rev Mex Ing Quim 14:321–334
Theuerl S, Klang J, Hülsemann B, Mächtig T, Hassa J (2020) Microbiome diversity and community-level change points within manure-based small biogas plants. Microorganisms 8:1169. https://doi.org/10.3390/microorganisms8081169
Tian-Qiong S, Hui P, Si-Yu Z, Rong-Yu J, Kun S, He H, Xiao-Jun J (2017) Microbial production of plant hormones: opportunities and challenges. Bioengineered 8:124–128. https://doi.org/10.1080/21655979.2016.1212138
Wang Y, Zhang H, Zhu L, Xu Y, Liu N, Sun X, Hu L, Huang H, Wei K, Zhu R (2018) Dynamic distribution of gut microbiota in goats at different ages and health states. Front Microbiol 9:2509. https://doi.org/10.3389/fmicb.2018.02509
Wang D, Huang Y, Xu Q, Liu X, Yang Q, Li X (2019) Free ammonia aids ultrasound pretreatment to enhance short-chain fatty acids production from waste activated sludge. Bioresour Technol 275:163–171. https://doi.org/10.1016/j.biortech.2018.12.055
Wang Q, Zhang P, Bao S, Liang J, Wu Y, Chen N, Wang S, Cai Y (2020) Chain elongation performances with anaerobic fermentation liquid from sewage sludge with high total solid as electron acceptor. Bioresour Technol 306:123188. https://doi.org/10.1016/j.biortech.2020.123188
Younge NE, Newgard CB, Cotten CM, Goldberg RN, Muehlbauer MJ, Bain JR, Stevens RD, O’Connell TM, Rawls JF, Seed PC, Ashley PL (2019) Disrupted maturation of the microbiota and metabolome among extremely preterm infants with postnatal growth failure. Sci Rep 9:8167. https://doi.org/10.1038/s41598-019-44547-y
Yu M, Li Z, Chen W, Rong T, Wang G, Ma X (2019) Microbiome-metabolomic analysis investigating the impacts of dietary starch types on the composition and metabolism of colonic microbiota in finishing pigs. Front Microbiol 10:1143. https://doi.org/10.3389/fmicb.2019.01143
Yuan Y, Hu X, Chen H, Zhou Y, Zhou Y, Wang D (2019) Advances in enhanced volatile fatty acid production from anaerobic fermentation of waste activated sludge. Sci Total Environ 694:133741. https://doi.org/10.1016/j.scitotenv.2019.133741
Zhou M, Yan B, Wong JWC, Zhang Y (2018) Enhanced volatile fatty acids production from anaerobic fermentation of food waste: a mini-review focusing on acidogenic metabolic pathway. Bioresour Technol 248:68–78. https://doi.org/10.1016/j.biortech.2017.06.121