Design and development of a portable low-cost QCM-based system for liquid biosensing
Tóm tắt
Quartz crystal microbalance (QCM) is a versatile sensing platform that has gained increasing attention for its use in bioapplications due to its high sensitivity, real-time measurement capabilities, and label-free detection. This article presents a portable QCM system for liquid biosensing that uses a modified Hartley oscillator to drive 14 mm-diameter commercial QCM sensors. The system is designed to be low-cost, easy to use, and highly sensitive, making it ideal for various bioapplications. A new flow cell design to deliver samples to the surface of the sensor has been designed, fabricated, and tested. For portability and miniaturization purposes, a micropump-based pumping system is used in the current system. The system has a built-in temperature controller allowing for accurate frequency measurements. In addition, the system can be used in benchtop mode. The capability of the present system to be used in liquid biosensing is demonstrated through an experimental test for sensitivity to changes in the viscosity of glycerol samples. It was found to have a sensitivity of 263.51 Hz/mPa.s using a 10 MHz QCM sensor. Future work regarding potential applications was suggested.
Tài liệu tham khảo
M. Adel, A. Allam, A.E. Sayour, H.F. Ragai, S. Umezu, A.M.R. Fath El-Bab, Micromachines 14, 1340 (2023). https://doi.org/10.3390/MI14071340
R. Aflaha, H. Afiyanti, Z.N. Azizah, H. Khoirudin, A. Rianjanu, A. Kusumaatmaja, R. Roto, K. Triyana, Biosens. Bioelectron. X 13, 100300 (2023a). https://doi.org/10.1016/j.biosx.2022.100300
R. Aflaha, L. Katriani, A.H. As’ ari, N.L.I. Sari, A. Kusumaatmaja, A. Rianjanu, R. Roto, K. Triyana, MRS Commun. 13, 664 (2023b). https://doi.org/10.1557/s43579-023-00409-3
R. Aflaha, N.L.I. Sari, L. Katriani, A.H. As’ ari, A. Kusumaatmaja, A. Rianjanu, R. Roto, H.S. Wasisto, K. Triyana, Microchem. J. 193, 109237 (2023c). https://doi.org/10.1016/j.microc.2023.109237
A. Alassi, M. Benammar, D. Brett, Sensors 17, 2799 (2017). https://doi.org/10.3390/s17122799
M.B. Banerjee, S.R. Chowdhury, R.B. Roy, B. Tudu, M. Ghosh, P. Pramanik, R. Bandyopadhyay, IEEE Trans. Instrum. Meas. 70, 1 (2020). https://doi.org/10.1109/TIM.2020.3020676
C. Barnes, Sensors Actuators A Phys. 29, 59 (1991). https://doi.org/10.1016/0924-4247(91)80032-K
C. Barnes, Sensors Actuators A Phys. 30, 197 (1992). https://doi.org/10.1016/0924-4247(92)80120-R
S. Beißner, J.-W. Thies, C. Bechthold, P. Kuhn, B. Thürmann, S. Dübel, A. Dietzel, J. Sensors Sens. Syst. 6, 341 (2017). https://doi.org/10.5194/jsss-6-341-2017
M. Calero, R. Fernández, P. García, J.V. García, M. García, E. Gamero-Sandemetrio, I. Reviakine, A. Arnau, Y. Jiménez, Biosensors 10, 189 (2020). https://doi.org/10.1016/j.sna.2017.08.004
W.-J. Chang, D. Akin, M. Sedlak, M.R. Ladisch, R. Bashir, Biomed. Microdevices 5, 281 (2003). https://doi.org/10.1023/A:1027301628547
E. Chiarello, A. Gupta, G. Mistura, M. Sbragaglia, M. Pierno, Phys. Rev. Fluids 2, 123602 (2017). https://doi.org/10.1103/PhysRevFluids.2.123602
N. Debabhuti, S. Mukherjee, P. Sharma, B. Tudu, N. Bhattacharyya, R. Bandyopadhyay, J. Mater. Nanosci. 9, 115 (2022). https://pubs.thesciencein.org/journal/index.php/jmns/article/view/288
D.D. Erbahar, I. Gürol, G. Gümüş, E. Musluoğlu, Z.Z. Öztürk, V. Ahsen, M. Harbeck, Sensors Actuators B Chem. 173, 562 (2012). https://doi.org/10.1016/j.snb.2012.07.041
V. Faustino, S.O. Catarino, R. Lima, G. Minas, J. Biomech. 49, 2280 (2016). https://doi.org/10.1016/j.jbiomech.2015.11.031
A. Fulgione, M. Cimafonte, B. Della Ventura, M. Iannaccone, C. Ambrosino, F. Capuano, Y.T. R. Proroga, R. Velotta, R. Capparelli, Sci. Rep. 8, 16137 (2018). https://doi.org/10.1038/s41598-018-34285-y
G. García-Martinez, E.A. Bustabad, H. Perrot, C. Gabrielli, B. Bucur, M. Lazerges, D. Rose, L. Rodriguez-Pardo, J. Fariña, C. Compère, Sensors 11, 7656 (2011). https://doi.org/10.3390/s110807656
J. Greener, W. Li, J. Ren, D. Voicu, V. Pakharenko, T. Tang, E. Kumacheva, Lab Chip 10, 522 (2010). https://doi.org/10.1039/B918834G
H.A. Huellemeier, N.M. Eren, J. Ortega-Anaya, R. Jimenez-Flores, D.R. Heldman, Chem. Eng. Sci. 247, 117004 (2022). https://doi.org/10.1016/j.ces.2021.117004
M.M. Islam, A. Loewen, P.B. Allen, Sci. Rep. 8, 8763 (2018). https://doi.org/10.1038/s41598-018-27037-5
P.J. Jandas, J. Luo, A. Quan, C. Li, C. Fu, Y.Q. Fu, RSC Adv. 10, 4118 (2020). https://doi.org/10.1039/C9RA09963H
I.R. Jang, S.I. Jung, G. Lee, I. Park, S.B. Kim, H.J. Kim, J. Hazard. Mater. 424, 127560 (2022). https://doi.org/10.1016/j.jhazmat.2021.127560
H. Khoirudin, R. Aflaha, E.R. Arsetiyani, A.D. Nugraheni, D.K. Nurputra, K. Triyana, A. Kusumaatmaja, MRS Commun. 1 (2023). https://doi.org/10.1557/s43579-023-00492-6
C. Koçum, A. Erdamar, H. Ayhan, Instrum. Sci. Technol. 38, 39 (2009). https://doi.org/10.1016/0924-4247(92)80120-R
K.-R. Lee, Y.-J. Kim, Sensors Actuators A Phys. 333, 113272 (2022). https://doi.org/10.1016/j.sna.2021.113272
N. Li, X. Meng, J. Nie, L. Lin, IEEE Sens. J. 18, 5715 (2018). https://doi.org/10.1109/JSEN.2018.2840124
J. Liang, J. Zhang, P. Wang, C. Liu, S. Qiu, T. Ueda, Sensors Mater. 28, (2016). https://doi.org/10.18494/SAM.2016.1281
C. Lino, S. Barrias, R. Chaves, F. Adega, J.R. Fernandes, P. Martins-Lopes, Talanta 260, 124624 (2023). https://doi.org/10.1016/j.talanta.2023.124624
M. Magni, D. Scaccabarozzi, B. Saggin, Sensors 23, 24 (2022). https://doi.org/10.3390/s23010024
G.A. Mannella, V. La Carrubba, V. Brucato, Appl. Therm. Eng. 63, 234 (2014). https://doi.org/10.1016/j.applthermaleng.2013.10.069
M. Michalzik, R. Wilke, S. Büttgenbach, Sensors Actuators B Chem. 111, 410 (2005). https://doi.org/10.1016/j.snb.2005.03.048
C.A. Mills, K.T.C. Chai, M.J. Milgrew, A. Glidle, J.M. Cooper, D.R.S. Cumming, IEEE Sens. J. 6, 996 (2006). https://doi.org/10.1109/JSEN.2006.877936
G.A. Nasser, A.L. Abdel-Mawgood, A.A. Abouelsoud, H. Mohamed, S. Umezu, A.M.R.F. El-Bab, J. Mech. Sci. Technol. 35, 3259 (2021). https://doi.org/10.1007/s12206-021-0646-5
G.A. Nasser, A.M.R. Fath El-Bab, A.L. Abdel-Mawgood, H. Mohamed, A.M. Saleh, Micromachines 10, 678 (2019). https://doi.org/10.3390/mi10100678
S. Nowocień, R.S. Wielgus, J. Mroczka, Sensors 22, 8525 (2022). https://doi.org/10.3390/s22218525
J.-Y. Park, J.-W. Choi, J. Electrochem. Soc. 167, 37560 (2020). https://doi.org/10.1149/1945-7111/ab6cf7
J.-Y. Park, R.L. Pérez, C.E. Ayala, S.R. Vaughan, I.M. Warner, J.-W. Choi, Electronics 11, 358 (2022). https://doi.org/10.3390/electronics11030358
M. Pohanka, Int J Electrochem Sci. 16, 21051 (2021). https://doi.org/10.20964/2021.05.04
S.B. Riffat, X. Ma, Appl. Therm. Eng. 23, 913 (2003). https://doi.org/10.1016/S1359-4311(03)00012-7
L. Rodriguez-Pardo, J. Farina, C. Gabrielli, H. Perrot, R. Brendel, IEEE Trans. Ultrason. Ferroelectr. Freq. Control 54, 1965 (2007). https://doi.org/10.1109/TUFFC.2007.490
L. Rodriguez-Pardo, J.F. Rodríguez, C. Gabrielli, H. Perrot, R. Brendel, IEEE Trans. Instrum. Meas. 57, 2309 (2008). https://doi.org/10.1109/TIM.2008.922104
L. Rodriguez-Pardo, A. Cao-Paz, J. Fariña, Procedia Eng. 25, 1257 (2011). https://doi.org/10.1016/j.proeng.2011.12.310
B.P. Sagmeister, I.M. Graz, R. Schwödiauer, H. Gruber, S. Bauer, Biosens. Bioelectron. 24, 2643 (2009). https://doi.org/10.1016/j.bios.2009.01.023
L. Sartore, M. Barbaglio, L. Borgese, E. Bontempi, Sensors Actuators B Chem. 155, 538 (2011). https://doi.org/10.1016/j.snb.2011.01.003
R. Suzuki, T. Emura, Y. Tokura, N. Kawamura, Y. Hori, IEEE Access 8, 146166 (2020). https://doi.org/10.1109/ACCESS.2020.3013857
P. Tetyana, P. M. Shumbula, Z. Njengele-Tetyana, In Nanopores (IntechOpen, 2021). https://doi.org/10.5772/intechopen.97576
J.-W. Thies, B. Thürmann, A. Vierheller, A. Dietzel, Micromachines 9, 194 (2018). https://doi.org/10.3390/mi9040194
R.D. Vaughan, R.M. Carter, C.K. O’Sullivan, G.G. Guilbault, Anal. Lett. 36, 731 (2003). https://doi.org/10.1081/AL-120018796
S. Wachiralurpan, I. Phung-On, N. Chanlek, S. Areekit, K. Chansiri, P.A. Lieberzeit, Biosensors 11, 308 (2021). https://doi.org/10.3390/bios11090308
F. Wudy, M. Multerer, C. Stock, G. Schmeer, H.J. Gores, Electrochim. Acta 53, 6568 (2008). https://doi.org/10.1016/j.electacta.2008.04.079
E. Zampetti, A. Macagnano, P. Papa, A. Bearzotti, F. Petracchini, L. Paciucci, N. Pirrone, Sensors Actuators A Phys. 264, 205 (2017). https://doi.org/10.1016/j.sna.2017.08.004