Comparative Analysis of Spontaneous Combustion Hazard Characteristics in Upside and Downside Ventilation Airflow Adopted Mining Areas
Allerton Press - 2024
Tóm tắt
To comparatively analyze the distribution characteristics of spontaneous combustion hazard zones in upside and downside ventilation airflow adopted mining areas, field measurements of O2 and CO concentrations were determined at the two sides of intake and return airways and the middle of the goaf in 1201 working face of DuanWang Mine; characteristic combustion temperatures and spontaneous ignition kinetic parameters of coal samples were obtained by thermogravimetric analysis; distributions of oxygen and temperature fields under different heat source intensities in upside and downside ventilation airflow adopted working faces were compared by CFD simulation. The results show that the critical positions of the inertisation zone in the goaf corresponding to the intake side, return side and middle of the working face were 200 m, 290 m and 175 m away from the working face, respectively; the moisture evaporating temperature of the coal sample was around 170°C, and the ignition point temperature was about 320°C. When the heat flux was 0 W/m2, the areas of spontaneous combustion hazard zones (oxygen volume fraction >8%) in upside and downside ventilation airflows adopted goafs were almost the same; as the heat source increased, the distribution of spontaneous combustion hazard zones in the goaf was more significantly affected by the hot wind pressure, the hazardous area in upside ventilation goaf was about 3 times of that in downside ventilation when the heat flux reached 20 W/m2. The simulation laws were consistent with the measured results. The comparative analysis concludes that downside ventilation is conducive to preventing and controlling spontaneous combustion of residual coal in this working face.
Từ khóa
Tài liệu tham khảo
Wang, X.G., Chen, Z.P., and Gong, B.J., Research and application of fire prevention technology in the top coal with super thick coal seam prone to spontaneous combustion, Foreign Lang. Sci. Technol. J. Database Eng. Technol., 2021, no. 10, pp. 146–148. https://doi.org/10.47939/et.v3i9(07).33
Wang, W.H., Study on the distribution pattern of coal spontaneous combustion hazard area in the overlying waterlogged mining area of the Tiailianta Mine, Jiangsu: China Univ. of Mining and Technology, 2019.
Ren, X.C., Practice of fire prevention and control in fully mechanized working face of composite coal seam prone to spontaneous combustion in positive pressure ventilation mine, Min. Saf. Environ. Prot., 2022, vol. 49, no. 1, pp. 90–93.
Xing, Z.Q., Chen, Y., Wang, W., Wang, C.S., and He, X.P., Fire prevention and control technology for large mining height workface in close distance coal, Saf. Coal Mines, 2016, vol. 47, no. 7, pp. 59–61.
Zhang, X.L., Zhang, X.D., and Ge, X.L., A new fire prevention and control strategy in the mining area, Coal Mine Saf., 2014, vol. 45, no. 10, pp. 120–122.
Zhu, Y.F., Wang, D.M., and Li, D.L., Statistical analysis of serious accidents in coal mines in China from 2000-2016, Energy Environ. Prot., 2018, vol. 40, no. 9, pp. 40–43.
Lv, Y.H., Wang, W., and Chen, M.G., Slurry anti-firefighting technology and its application in oversized mining areas of near coal seam clusters, Coal Mine Saf., 2018, vol. 49, no. S1, pp. 30–35.
Yang, S.Q., Xu, Q., and Huang, J., The “three zones” microcirculation theory of goaf spontaneous combustion and a numerical simulation of the air leakage flow field, J. China Univ. Min. Technol., 2009, vol. 38, no. 6, pp. 769–773.
Lin, L., Li, Z., Zhang, M., Miao, C., Jia, N., and Liu, Ya., Study on spontaneous combustion law and prevention technology of abandoned coal in goaf of coal mine, Geofluids, 2018, vol. 2023, no. 2, p. 5535774. https://doi.org/10.1155/2023/5535774
Liu, Z.W., Shi, J.S., and Fu, Q., Influence of upward and downward ventilations on dangerous area of spontaneouscombustion in large dip goaf of Dongxia Coal Mine, Coal Technol., 2020, vol. 39, no. 8, pp. 129–132.
Gao, J.L., Guo, F.P., and Zhang, X.B., Effects of the mining-face ventilation mode on the air-current field as well as the gasmovement in the gob, J. Saf. Environ., 2011, vol. 11, no. 5, pp. 168–171.
Hu, D. and Li, Z., Dynamic distribution and prevention of spontaneous combustion of coal in gob-side entry retaining goaf, PLoS ONE, 2022, vol. 17, no. 5, p. e0267631. https://doi.org/10.1371/journal.pone.0267631
Qin, B.T. and Wang, D.M., Present situation and development of intelligent coal mine safety monitoring system, China Saf. Sci. J., 2007, no. 12, pp. 80–85+193.
Li, Z., Hu, D., Liu, Yu., Li, Yu., and Miao, C., Method for determining spontaneous combustion risk in roof cutting gob-side entry retaining U + L ventilation goaf for mining safety, Geofluids, 2022, vol. 2022, p. 7489550. https://doi.org/10.1155/2022/7489550
Li, Z.X., New progress of theory of field flow safety in goaf and its study, China Saf. Sci. J., 2005, vol. 15, no. 12, pp. 85–88.
Shen, Y.D., Experimental study of high-efficiency foam fire extinguishing agent for preventing spontaneous combustion of coal, Beijing: China Univ. of Mining and Technology, 2018.
Yu, M.G., Teng, F., and Chu, X.T., Simulation study on the evolution of the overlying strata fractures and air-leaking passage under repeated mining of shallow buried coal seams, J. Henan Polytechnic Univ. (Nat. Sci.), 2018, vol. 37, no. 1, pp. 1–7.
Jiao, Y.J., Zhu, J.F., and Geng, Y., Study on 3D distribution of porosity of overburden “horizontal three-zones” in goaf, Saf. Coal Mines, 2021, vol. 52, no. 11, pp. 159–165.
Sun, J., Effect of mining pore thickness in longwall goaf, Saf. Coal Mines, 2019, vol. 50, no. 10, pp. 49–53.
Si, J.H., Li, T., Hu, W., and Wang, Y.Q., Research on the characterization algorithm of equivalent pore net- work topological structure of porous media in goaf, J. North China Acad. Sci. Technol., 2022, vol. 19, no. 1, pp. 1–6.
Deng, J., Practice of low oxygen control in the first mining face of Qinglongsi Coal Mine, Saf. Coal Mines, 2021, vol. 52, no. 5, pp. 78–81.
Guo, H.X., Prevention and control technology and goaf spontaneous combustion index in distance coal seams, Saf. Coal Mines, 2022, vol. 53, no. 4, pp. 74–80.