Evaluation of thin film p-type single crystal silicon for use as a CMOS Resistance Temperature Detector (RTD)

Udrea, 2008, CMOS temperature sensors-concepts, state-of-the-art and prospects Haneef, 2007, High performance SOI-CMOS wall shear stress sensors Udrea, 2001, Design and simulations of SOI CMOS micro-hotplate gas sensors, Sens. Actuators B Chem., 78, 180, 10.1016/S0925-4005(01)00810-3 Nilsson, 2017, High-temperature characterisation and analysis of leakage-current-compensated, low-power bandgap temperature sensors, Analog Integr. Circuits Signal Process., 93, 137, 10.1007/s10470-017-1011-6 Chung, 2008, RTD characteristics for micro-thermal sensors, Microelectron. J., 39, 1560, 10.1016/j.mejo.2008.02.028 Kamat, 2002, Thermistors–in search of new applications, manufacturers cultivate advanced NTC techniques, Sens. Rev., 22, 334, 10.1108/02602280210444654 Childs, 2000, Review of temperature measurement, Rev. Sci. Instrum., 71, 2959, 10.1063/1.1305516 Kim, 2001, A study on the fabrication of an RTD (resistance temperature detector) by using Pt thin film, Korean J. Chem. Eng., 18, 61, 10.1007/BF02707199 El-Ali, 2004, Simulation and experimental validation of a SU-8 based PCR thermocycler chip with integrated heaters and temperature sensor, Sens. Actuators A Phys., 110, 3, 10.1016/j.sna.2003.09.022 Moser, 2007, Miniaturized flexible temperature sensor, J. Microelectromechanical Syst., 16, 1349, 10.1109/JMEMS.2007.908437 Xiao, 2008, A novel fabrication process of MEMS devices on polyimide flexible substrates, Microelectron. Eng., 85, 452, 10.1016/j.mee.2007.08.004 Bentley, 1984, Temperature sensor characteristics and measurement system design, J. Phys. E, 17, 430, 10.1088/0022-3735/17/6/002 He, 2006, Thin film temperature sensor for real-time measurement of electrolyte temperature in a polymer electrolyte fuel cell, Sens. Actuators A Phys., 125, 170, 10.1016/j.sna.2005.05.021 Lee, 2008, Fabrication of micro sensors on a flexible substrate, Sens. Actuators A Phys., 147, 173, 10.1016/j.sna.2008.05.004 Ahn, 2013, Direct fabrication of thin film gold resistance temperature detection sensors on a curved surface using a flexible dry film photoresist and their calibration up to 450 °C, J. Micromech. Microeng., 23, 065031, 10.1088/0960-1317/23/6/065031 Phatthanakun, 2012, Design and fabrication of thin-film aluminum microheater and nickel temperature sensor, 7th IEEE International Conference on Nano/Micro Engineered and Molecular Systems (NEMS'12) Santos, 2018, RTD-based smart temperature sensor: process development and circuit design, 26th IEEE International Imran, 2006, Effect of thin film thicknesses and materials on the response of RTDs and microthermocouples, IEEE Sens. J., 6, 1459, 10.1109/JSEN.2006.884167 Wang, 2015, Multifunctional platform with CMOS-compatible tungsten microhotplate for pirani, temperature, and gas sensor, Micromachines, 6, 1597, 10.3390/mi6111443 Stankevič, 1998, Application of aluminum films as temperature sensors for the compensation of output thermal shift of silicon piezoresistive pressure sensors, Sens. Actuators A Phys., 71, 161, 10.1016/S0924-4247(98)00178-2 Dugaev, 2002, Characterization and modeling of Ge film thermometers for low temperature measurements, IEEE Proceedings on Sensors, 10.1109/ICSENS.2002.1037300 Agarwal, 2008, Silicon nanowire sensor array using top–down CMOS technology, Sens. Actuators A Phys., 145, 207, 10.1016/j.sna.2007.12.019 Bendekovic, 1998, Polysilicon temperature sensor, 9th IEEE Mediterranean Electrotechnical Conference (MELECON' 98), 10.1109/MELCON.1998.692428 Wasa, 1979, Highly‐reliable temperature sensor using RF-sputtered SiC thin film, Rev. Sci. Instrum., 50, 1084, 10.1063/1.1135988 Obermeier, 1992, Polysilicon as a material for microsensor applications, Sens. Actuators A Phys., 30, 149, 10.1016/0924-4247(92)80210-T Haneef, 2009 Arai, 2004, Ultra-small site temperature sensing by carbon nanotube thermal probes, 4th IEEE Conference on Nanotechnology Blasdel, 2015, Fabric nanocomposite resistance temperature detector, IEEE Sens. J., 15, 300, 10.1109/JSEN.2014.2341915 Yadav, 2012 Wang, 2017, Fabrication and characterization of ITO thin film resistance temperature detector, Vacuum, 140, 121, 10.1016/j.vacuum.2016.07.028 McGee, 1988 Mansoor, 2014, SOI CMOS multi-sensors MEMS chip for aerospace applications, IEEE Conference on Sensors De Luca, 2015, High-sensitivity single thermopile SOI CMOS MEMS thermal wall shear stress sensor, IEEE Sens. J., 15, 5561, 10.1109/JSEN.2015.2444798 Sze, 2006 Boukabache, 2002, Doping effects on thermal behaviour of silicon resistor, Electron. Lett., 38, 342, 10.1049/el:20020221 Norton, 1978, Temperature coefficient of resistance for p- and n-type silicon, Solid-State Electron., 21, 969, 10.1016/0038-1101(78)90296-4 Clayton, 1988, Thin-film platinum for appliance temperature control, IEEE Trans. Ind. Appl., 24, 332, 10.1109/28.2875 Kreider, 2009, Thin-film resistance thermometers on silicon wafers, Meas. Sci. Technol., 20, 045206, 10.1088/0957-0233/20/4/045206 D’Aleo, 2012, Design, calibration and testing of a thin film temperature gauge array for temperature and heat flux measurements in fluid mixing experiments, Flow Meas. Instrum., 24, 29, 10.1016/j.flowmeasinst.2012.03.002 Han, 2014, MEMS-based Pt film temperature sensor on an alumina substrate, Mater. Lett., 125, 224, 10.1016/j.matlet.2014.03.170 Zribi, 2016, Design, fabrication and characterization of thin film resistances for heat flux sensing application, Sens. Actuators A Phys., 245, 26, 10.1016/j.sna.2016.04.040 Wang, 2016, High temperature sensors fabricated on Al2O3 ceramic and nickel-based superalloy substrates, Sens. Actuators A Phys., 247, 75, 10.1016/j.sna.2016.05.048 Lichtenwalner, 2007, Flexible thin film temperature and strain sensor array utilizing a novel sensing concept, Sens. Actuators A Phys., 135, 593, 10.1016/j.sna.2006.07.019 Maher, 2014, Modelling of temperature coefficient of resistance of a thin film RTD towards exhaust gas measurement applications Aviles, 2005, Physical properties of Au and Al thin films measured by resistive heating, Surf. Rev. Lett., 12, 101, 10.1142/S0218625X05006834 Lee, 2007, Fabrication of micro temperature sensor on the flexible substrate Lee, 2009, Fabrication of micro temperature sensor and heater in a stainless steel-based micro reformer Lee, 2010, Sensor fabrication method for in situ temperature and humidity monitoring of light emitting diodes, Sensors, 10, 3363, 10.3390/s100403363 Lee, 2011, Fabrication of a flexible micro temperature sensor for micro reformer applications, Sensors, 11, 3706, 10.3390/s110403706 Wang, 2014, Development of a micro temperature sensor and 3D temperature analysis for a proton exchange membrane fuel cell, Fuel Cells, 14, 626, 10.1002/fuce.201300200 Fenn, 1998, Electrical resistivity of Cu and Nb thin films, J. Phys. Condens. Matter, 10, 1707, 10.1088/0953-8984/10/8/007 Kim, 2015, Resistance temperature detector sensor with a copper pattern on the printed circuit board, Int. J. Control. Autom., 8, 67, 10.14257/ijca.2015.8.8.08 Starý, 1981, Electrical resistivity and structure of thin nickel films – effect of annealing, Vacuum, 31, 345, 10.1016/S0042-207X(81)80041-3 Pacardo, 2015, A temperature microsensor for measuring laser-induced heating in gold nanorods, Anal. Bioanal. Chem., 407, 719, 10.1007/s00216-014-8222-9 Choi, 2012, Electron mean free path of tungsten and the electrical resistivity of epitaxial (110) tungsten films, Phys. Rev.: B, 86, 045432, 10.1103/PhysRevB.86.045432 Martinez-Quijada, 2013, Fabrication and characterization of aluminum thin film heaters and temperature sensors on a photopolymer for lab-on-chip systems, Sens. Actuators A Phys., 193, 170, 10.1016/j.sna.2013.01.035 Zhou, 2007, Structure and electronic properties of SiC thin-films deposited by RF magnetron sputtering, Trans. Nonferrous Met. Soc. China, 17, 373, 10.1016/S1003-6326(07)60101-0 Urban, 1990, High-resolution thin-film temperature sensor arrays for medical applications, Sens. Actuators A Phys., 22, 650, 10.1016/0924-4247(89)80051-2 Fritzsche, 1955, Electrical properties of germanium semiconductors at low temperatures, Phys. Rev., 99, 406, 10.1103/PhysRev.99.406 Boltovets, 2003, New generation of resistance thermometers based on Ge films on GaAs substrates Mitin, 2007, Ge-on-GaAs film resistance thermometers for cryogenic applications, Cryogenics, 47, 474, 10.1016/j.cryogenics.2007.04.014 Lee, 2011, Design, fabrication and characterization of a thermal microsystem integrated with heaters, pressure and temperature microsensors, J. Micromech. Microeng., 21, 10.1088/0960-1317/21/12/125021 Bauer, 2007, Electrical properties of nominally undoped silicon nanowires grown by molecular-beam epitaxy, Appl. Phys. Lett., 90, 10.1063/1.2428402 Demami, 2011, Electrical properties of polysilicon nanowires for device applications, Physica Status Solidi: C, 8, 827, 10.1002/pssc.201000227 Fung, 2004, Dielectrophoretic batch fabrication of bundled carbon nanotube thermal sensors, IEEE Trans. Nanotechnol., 3, 395, 10.1109/TNANO.2004.834156 Masahito, 2011, Measuring the electrical resistivity and contact resistance of vertical carbon nanotube bundles for application as interconnects, Nanotechnology, 22 Mahanandia, 2008, Possible application of carbon nanotube bundles for low temperature sensing, Rev. Sci. Instrum., 79, 053909, 10.1063/1.2932343 Jouguelet, 1998, Electrical resistivity of single-wall carbon nanotubes obtained by the arc-discharge technique Yang, 2010, High sensitivity temperature sensor based on a long, suspended single-walled carbon nanotube array, Micro Nano Lett., 5, 157, 10.1049/mnl.2010.0005 Neella, 2016, Negative temperature coefficient behavior of graphene-silver nanocomposite films for temperature sensor applications Hussain, 2013, Synthesis of carbon nano-fibers on p-Si having improved temperature sensing capability, Mater. Sci. Eng. B, 178, 83, 10.1016/j.mseb.2012.10.007 Kasumov, 1996, Electrical resistance of a single carbon nanotube, Europhys. Lett., 34, 429, 10.1209/epl/i1996-00474-0 Nehru, 2012, Studies on structural, optical and electrical properties of ZnO thin films prepared by the spray pyrolysis method, Int. J. Mater. Eng., 2, 12, 10.5923/j.ijme.20120201.03